The 1991 Plymouth Grand Voyager has 6 NHTSA recall campaigns affecting an estimated 5,342,748 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 199 complaints with NHTSA, most often about the service brakes, hydraulic. Last updated July 5, 2026.
Recall campaigns
STRUCTURE99V2130001999-09-021,318,189 affected
Defect
VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN…
Consequence
PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy
DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
VISIBILITY99V1890001999-07-16828,559 affected
Defect
VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.
Consequence
THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.
SEAT BELTS97V1480001997-09-091,100,000 affected
Defect
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.
Consequence
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy
DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.
SEAT BELTS97V1490001997-09-091,100,000 affected
Defect
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.
Consequence
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy
DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.
STEERING96V2290001996-11-18675,000 affected
Defect
THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence
IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy
DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
SERVICE BRAKES, HYDRAULIC96V0990001996-06-13321,000 affected
Defect
THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
Consequence
IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy
DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE…
Complaints by component
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
4
Total complaints199
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Tl* the contact owns a 1991 plymouth grand voyager. The contact stated that the brake system failed. The contact had to engage the brake pedal with force to bring the vehicle to a complete stop. The contact spoke with baxter chrysler, dodge, jeep, ram, lincoln dealer (6601 telluride drive a…”
“Tl* the contact owns a 1991 plymouth grand voyager. The contact stated that while driving 45 mph, the brake light illuminated. When the contact attempted to apply the brakes, tried the brakes became resistant and the contact felt as if he was attempting to push a ton of bricks. The vehicle was…”
“Tl* the contact owns a 1991 plymouth grand voyager le. The contact stated that there was a leak in the fuel rail. The vehicle was taken to a local mechanic for routine maintenance where they discovered the fuel leak. The manufacturer was notified of the failure who advised that the vehicle was too…”
“Tl*the contact owns a 1991 plymouth grand voyager. The contact took the vehicle to the dealer for a braking system diagnostic. He stated that both brake lights would illuminate, but the brake assist would not engage. The diagnostic indicated that a hydraulic assembly, pump motor, and accumulator…”
“Tl*the contact owns a 1991 plymouth grand voyager. The abs warning indicator light illuminated. The dealer stated that the abs cab controller needed to be replaced; however, the part was no longer being manufactured. She was advised to check with a salvage yard. The part was previously replaced at…”
“Tl*the contact owns a 1991 plymouth grand voyager. The abs warning indicator light illuminated. The dealer stated that the abs cab controller needed to be replaced; however, the part was no longer being manufactured. She was advised to check with a salvage yard. The part was previously replaced at…”
“We own a 1991 plymouth grand voyager. On january 9, 2006 the abs warning light illuminated. We had the brakes of our plymouth grand voyager supposedly fixed by crown chrysler in greensboro, nc at this time. We bought the car to the dealership based on nhtsa campaign id number 96v099000 (service…”
“Dt*: the contact stated there was a strong odor of gasoline present in the vehicle. The vehicle was inspected by an independent repair shop. The mechanic determined the fuel rails were leaking. Although the problem persisted, the fuel rails were not replaced. There is a nhtsa recall # 98v130000…”
Defect investigations
InvestigationEA94005 Opened 1994-01-31 · closed 1995-10-25
LIFTGATE LATCHES
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM…
InvestigationEA94028 Opened 1994-07-29 · closed 1996-06-24
ABS BRAKING SYSTEM FAILS
There is no summary currently available
InvestigationEA95029 Opened 1995-09-26 · closed 1996-11-13
STEERING WHEEL SEPARATION
AFTER AN EXTENSIVE INVESTIGATION AND ANALYSIS, CHRYSLER HAS IDENTIFIED THE DEFECT AS A FATIGUE FAILURE, ORIGINATION IN THE HEAT AFFECTED REGION OF THE PROJECTION WELDS OF THE STEERING WHEEL HUB TO STEERING WHEEL ARMATURE ATTACHMENT.THE HUB IS THE PORTION OF THE STEERING WHEEL ASSEMBLY THAT CONNECTS IT TO THE STEERING…
InvestigationPE94024 Opened 1994-03-07 · closed 1994-07-29
ABS BRAKING SYSTEM FAILS
There is no summary currently available
InvestigationRQ99004 Opened 1999-04-19 · open
REAR LIFTGATE SUPPORT
ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991-1993 CHRYSLER…
InvestigationRQ99004 Opened 1999-04-19 · open
REAR LIFTGATE SUPPORT
ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991-1993 CHRYSLER…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1991 Plymouth Grand Voyager as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.