RecallRepo

2019 Ford F-550 Sd Recalls

Recalls on record Updated July 2026

The 2019 Ford F-550 Sd has 5 NHTSA recall campaigns affecting an estimated 2,791,096 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 4 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.

Recall campaigns

BACK OVER PREVENTION 25V572000 2025-09-03 1,456,417 affected
Defect

Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or…

Consequence

A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy

Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is…

EQUIPMENT 23V420000 2023-06-09 691,133 affected
Defect

Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As…

Consequence

Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.

Remedy

Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.

BACK OVER PREVENTION 22V252000 2022-04-14 21,904 affected
Defect

Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety…

Consequence

A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.

Remedy

Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

SEAT BELTS 19V880000 2019-12-11 490,574 affected
Defect

Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

Consequence

A vehicle fire could result if materials ignite inside the vehicle.

Remedy

Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.

ENGINE 19V278000 2019-04-08 131,068 affected
Defect

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's…

Consequence

A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Remedy

Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at…

Complaints by component

ENGINE
2
1fires
FUEL/PROPULSION SYSTEM
1
1fires
TIRES
1
Total complaints4

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“The secondary fuel filter. There was a loud boom and the engine compartment caught on fire. Within 10 minutes the whole truck was engulfed in flames. The truck is completely burnt. The insurance company has inspected the vehicle. No warning lights on the console lit up, no prior symptoms or…”

FUEL/PROPULSION SYSTEM · reported 2026-05-27

“Between august 5 and august 9, 2025 we purchased 46 nebula brand 245/70r 19.5 16pr tires. We experienced a complete tire failure on one of our trucks while operating on the highway. Fortunately, our driver was able to safely steer the truck to the shoulder with minimal damage to the tow truck.…”

TIRES · reported 2026-05-13

“The operator was driving on the highway when the instrument cluster illuminated with a variety of warnings. The vehicle was pulled to the side of the highway and the operator exited to see the engine compartment was on fire. The vehicle was towed back to the yard and an initial inspection was…”

ENGINE · reported 2024-09-20

“Operator was completing an inspection of their secondary fuel filter and found that the newly replaced fuel filter was leaking fuel. The filter had been replaced on 5/31/24.”

ENGINE · reported 2024-06-17

Defect investigations

Investigation PE24014 Opened 2024-05-09 · open

Sogefi Secondary Diesel Fuel Filter Leak

The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe…

Investigation PE24014 Opened 2024-05-09 · open

Sogefi Secondary Diesel Fuel Filter Leak

The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2019 Ford F-550 Sd as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.