RecallRepo

1999 Chevrolet Venture Recalls

Recalls on record Updated July 2026

The 1999 Chevrolet Venture has 4 NHTSA recall campaigns affecting an estimated 1,443,109 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 467 complaints with NHTSA, most often about the engine and engine cooling. Last updated July 5, 2026.

Recall campaigns

LATCHES/LOCKS/LINKAGES 04V597000 2004-12-22 717,302 affected
Defect

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Consequence

IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy

DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR…

LATCHES/LOCKS/LINKAGES 01V264000 2001-08-21 248,737 affected
Defect

VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS…

Consequence

IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Remedy

DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT…

LATCHES/LOCKS/LINKAGES 01V067000 2001-03-08 477,011 affected
Defect

VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.

Consequence

AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Remedy

DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT…

STEERING 99V071000 1999-04-12 59 affected
Defect

VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.

Consequence

IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.

Remedy

DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.

Complaints by component

ENGINE AND ENGINE COOLING
44
2crashes1fires
STRUCTURE:BODY:DOOR
27
6injuries
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
25
AIR BAGS
23
3crashes3injuries
ENGINE AND ENGINE COOLING:ENGINE
20
POWER TRAIN:AUTOMATIC TRANSMISSION
20
ENGINE AND ENGINE COOLING:COOLING SYSTEM
18
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
13
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
13
1injuries
AIR BAGS:FRONTAL
12
8crashes12injuries1deaths
Total complaints467

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Tl* the contact owns a 1999 chevrolet venture. The contact stated that when starting the vehicle, the air bag warning light would flash 7 times then remained illuminated. The vehicle was taken to an independent mechanic and a diagnostic was performed, which located a failure code for the air bags.…”

AIR BAGS · reported 2017-06-28

“I need to know were I can find out who I tex to recall this van there are to many things thats going wrong with it I fix one thing and something else go wrong with it look I have cancer and need a good car to go to stanford cancer please can u help me.”

UNKNOWN OR OTHER · reported 2016-03-24

“Cpsc: i1480097a. 1999 chevy venture. Consumer stated that she has a defective vehicle. *ln”

UNKNOWN OR OTHER · reported 2014-06-20

“Tl* the contact owns a 1999 chevrolet venture. The contact stated while driving 40 mph and the vehicle stalled. The vehicle was towed to the contacts home. A mechanic diagnosed that the fuel line and fuel tank melted due to the exhaust. The contact patched up the fuel tank and the fuel line since…”

FUEL/PROPULSION SYSTEM · reported 2013-12-27

“In september of 2013 I noticed oil in coolant reservoir. Took to the mechanic. Closer inspection showed head gaskets were destroyed. Had the head gasket replaced and the coolant flushed out as well as changed all coolant hoses, water pump, and thermostat to the tune of $900.00 dollars. Vehicle…”

ENGINE · reported 2013-09-23

“My wife smelled gasoline upon entering the car on october 7, 2012. I checked under the car from where the smell was coming from, and saw gasoline dripping from a pipe near the gas tank. I brought the car to the local chevy dealership. I had to replace four fuel and evaporation lines due to…”

FUEL/PROPULSION SYSTEM · reported 2012-10-07

“Purchased vehicle brand new. Manifold gasket leak at 35,000 miles repaired by gm. Failed again at 70,000 miles but gm wouldn't cover the cost, paid $900 out of pocket. Now at 112,000 miles and suspect that it is in need of replacement again. The lifters are also making noise. The mechanics are…”

ENGINE AND ENGINE COOLING · reported 2011-02-07

“Tl* the contact owns a 1999 chevrolet venture. The contact was driving approximately 30 mph when she smelled a burning odor. She then noticed white smoke emitting from the front driver side door. The vehicle was driven to the side of the road and the engine was turned off. The contact and…”

ELECTRICAL SYSTEM · reported 2010-09-17

Defect investigations

Investigation EA03005 Opened 2003-04-23 · closed 2004-01-12

REAR AXLE TRAILING ARM FAILURE

ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE.…

Investigation EA03005 Opened 2003-04-23 · closed 2004-01-12

REAR AXLE TRAILING ARM FAILURE

ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE.…

Investigation PE00045 Opened 2000-11-03 · closed 2001-01-11

AIR BAG TEAR DURING DEPLOYMENT

Investigation PE02017 Opened 2002-02-11 · closed 2002-08-02

SHOULDER HARNESS CLIP

Investigation PE02086 Opened 2002-11-18 · closed 2003-04-09

REAR AXLE TRAILING ARM FAILURE

ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS…

Investigation PE02086 Opened 2002-11-18 · closed 2003-04-09

REAR AXLE TRAILING ARM FAILURE

ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS…

Investigation PE04064 Opened 2004-09-17 · closed 2004-12-22

POWER-SLIDING DOOR

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING…

Investigation SQ00014 Opened 2000-07-25 · closed 2001-10-22

UNEXPECTED OPENING OF SLIDING DOOR

There is no summary currently available

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1999 Chevrolet Venture as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.