RecallRepo

1997 Chevrolet Venture Recalls

Recalls on record Updated July 2026

The 1997 Chevrolet Venture has 6 NHTSA recall campaigns affecting an estimated 2,783,350 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 612 complaints with NHTSA, most often about the exterior lighting. Last updated July 5, 2026.

Recall campaigns

LATCHES/LOCKS/LINKAGES 04V597000 2004-12-22 717,302 affected
Defect

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Consequence

IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy

DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR…

STEERING 02V286000 2002-11-04 1,159,156 affected
Defect

CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.

Consequence

IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION…

Remedy

DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY…

LATCHES/LOCKS/LINKAGES 01V264000 2001-08-21 248,737 affected
Defect

VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS…

Consequence

IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Remedy

DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT…

LATCHES/LOCKS/LINKAGES 01V067000 2001-03-08 477,011 affected
Defect

VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.

Consequence

AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Remedy

DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT…

SEATS 98V145000 1998-06-26 125,990 affected
Defect

VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH BUCKET SEATS OR A SPLIT BENCH SEAT IN THE SECOND (MIDDLE) OR THIRD (BACK) ROW. THE SEAT LATCH MECHANISMS ON BUCKET SEATS AND ON THE 40% PORTION OF THE SPLIT BENCH SEAT IN THE SECOND AND THIRD ROWS DO NOT HAVE PROTECTIVE COVERS.

Consequence

WHEN ACTIVATING THE RELEASE MECHANISM TO ROLL A BUCKET SEAT FORWARD, A CUSTOMER'S FINGER(S) COULD BE SEVERELY INJURED OR SEVERED IN THEY ARE NOT KEPT CLEAR OF THE MECHANISM.

Remedy

DEALERS WILL INSTALL PROTECTIVE COVERS ON THE OUTBOARD LATCH MECHANISMS ON ALL LEFT AND RIGHT HAND REAR BUCKET SEATS IN THE SECOND AND THIRD ROW, AND TO BOTH INBOARD AND OUTBOARD LATCH MECHANISMS ON THE CENTER REAR BUCKET SEAT AND THE 40% PORTION OF THE SPLIT BENCH SEAT.

VISIBILITY 98V072000 1998-04-07 55,154 affected
Defect

VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH TRACTION CONTROL SYSTEMS. THE WINDSHIELD WIPER LINKAGE ARM CAN CONTACT A BRAKE LINE WHICH IS CONNECTED TO THE TRACTION CONTROL SYSTEM MODULATOR VALVE. THIS CONTACT CAN CHAFE THE BRAKE LINE RESULTING IN A BRAKE FLUID LEAK.

Consequence

BRAKE FLUID LEAKAGE CAN CAUSE REDUCED BRAKE EFFECTIVENESS AND INCREASED STOPPING DISTANCES.

Remedy

DEALERS WILL INSTALL A BRAKE LINE CLIP TO ENSURE PROPER CLEARANCE. ALSO THE BRAKE LINES WILL BE INSPECTED TO ANY DAMAGE CAUSED BY THIS CONDITION AND WILL REPLACE ANY DAMAGED LINES.

Complaints by component

EXTERIOR LIGHTING:HEADLIGHTS
51
1fires
STEERING:RACK AND PINION
42
1deaths
STRUCTURE:BODY:DOOR
41
ELECTRICAL SYSTEM:HORN
30
ENGINE AND ENGINE COOLING
28
1fires
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
18
1injuries
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
17
1fires
POWER TRAIN:AUTOMATIC TRANSMISSION
15
ENGINE AND ENGINE COOLING:COOLING SYSTEM
14
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
14
1crashes
Total complaints612

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Steering locked up on '97 venture van while being operated at 70 mph on a straight highway. Vehicle had to be towed, rack and pinion and steering pump replaced.”

STEERING · reported 2017-04-11

“Tl* the contact owns a 1997 chevrolet venture. Within less than 30 days of owning the vehicle, the service engine light and the coolant light randomly kept illuminating. The contact stated that the vehicle overheated. The mechanic was notified of the failure. The contact was awaiting the…”

ENGINE · reported 2016-07-18

“Rear brake lamps keep failing, light bar on top works fine but both side rear brake lamps fail continuously. Upon disassembly of brake light one can see the sockets and bulb contacts are melting. This van has already had the entire rear light assembly on each side replaced but problem is…”

EXTERIOR LIGHTING · reported 2012-04-11

“I bought 4 pep boys definity tires w road hasard total was 424.58 on 9/10/201. Mileage was152156..yesterday 9/1/2011 ihad a blow out on l rear tire. The mileage was158180. They told me it would be pro rated,only 6,000 miles and it cost me 41.52 for another tire. It couldnt be fixed. What was the…”

TIRES · reported 2011-09-01

“1997 chevrolet venture, unit 1 was eastbound in the far right lane. The hood apparently was not latched properly, flew up and back, shattering the windshield. Updated 04/04/2011 *bf (ohio traffic crash report #10-0175-90)*jb updated 04/22/11 *bf”

LATCHES/LOCKS/LINKAGES:HOOD:LATCH · reported 2011-02-26

“1997 chevrolet venture, caught fire and became fully engulfed causing total damage. *bf according to the police report, the vehicle had engine trouble. (ohio traffic crash report # 10-0318-89)*jb updated 09/13/10*bf”

ENGINE AND ENGINE COOLING · reported 2010-07-31

“I have owned 3 chevy venture minivans over the past 10 years. All of them had the same problems, the signal and head lights go out, the window switch goes out and finally the head gasket goes. They run great until the day it starts overheating, then your out a vehicle. Everyone I know who has a…”

ENGINE AND ENGINE COOLING · reported 2009-12-18

“I have owned 3 chevy venture minivans over the past 10 years. All of them had the same problems, the signal and head lights go out, the window switch goes out and finally the head gasket goes. They run great until the day it starts overheating, then your out a vehicle. Everyone I know who has a…”

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS · reported 2009-12-18

Defect investigations

Investigation DP04002 Opened 2004-02-03 · closed 2004-03-17

RACK AND PINION STEERING UNIT FAILURE

MR. DENNIS FIKE OF ELKRIDGE, MD, SUBMITTED A PETITION TO NHTSA BY LETTER DATED JANUARY 13, 2004, ALLEGING THAT A GM DEALER INFORMED HIM THAT HIS VAN WAS NOT INCLUDED IN SAFETY RECALL 02V286 AND CHARGED HIM FOR THE REPLACEMENT OF THE STEERING RACK AND PINION UNIT.MR. FIKE BELIEVES THAT HIS VAN SHOULD HAVE BEEN…

Investigation EA02003 Opened 2002-04-04 · closed 2002-12-10

POWER RACK AND PINION STEERING FAILURE

THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.

Investigation EA02003 Opened 2002-04-04 · closed 2002-12-10

POWER RACK AND PINION STEERING FAILURE

THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.

Investigation EA02032 Opened 2002-11-18 · closed 2003-11-21

SAFETY BELT ASSEMBLY FAILURE

ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE…

Investigation EA03005 Opened 2003-04-23 · closed 2004-01-12

REAR AXLE TRAILING ARM FAILURE

ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE.…

Investigation EA03005 Opened 2003-04-23 · closed 2004-01-12

REAR AXLE TRAILING ARM FAILURE

ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE.…

Investigation PE01038 Opened 2001-11-14 · closed 2002-04-04

STEERING RACK AND PINION

ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES…

Investigation PE02017 Opened 2002-02-11 · closed 2002-08-02

SHOULDER HARNESS CLIP

Investigation PE98030 Opened 1998-05-15 · closed 1998-06-30

FINGER CUTTING/PINCHING

ODI HAS RECEIVED THREE REPORTS INDICATING INJURIES OCCURRED TO CONSUMERS WHILE THEY WER FOLDING A SECOND ROW SEAT TO GAIN ACCES TO THE REAR OR THIRD ROW SEATS.WHEN FOLDING THE SEAT A PORTION OF THE SEAT FRAME MOVES IN A SCISSOR ACTION.TWO OF THE CONSUMERS SEVERED THE END OF THEIR FINGER AND THE THIRD SUFFERED A…

Investigation SQ00014 Opened 2000-07-25 · closed 2001-10-22

UNEXPECTED OPENING OF SLIDING DOOR

There is no summary currently available

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1997 Chevrolet Venture as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.