The 2002 Chevrolet Venture has 3 NHTSA recall campaigns affecting an estimated 871,117 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 284 complaints with NHTSA, most often about the engine and engine cooling. Last updated July 5, 2026.
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence
A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION…
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence
IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy
DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR…
AIR BAGS02V2220002002-08-09133,221 affected
Defect
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT…
Complaints by component
ENGINE AND ENGINE COOLING
20
1fires1injuries
ELECTRICAL SYSTEM
14
1crashes1fires
FUEL SYSTEM, GASOLINE
13
FUEL/PROPULSION SYSTEM
13
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
12
ENGINE AND ENGINE COOLING:COOLING SYSTEM
11
STRUCTURE:BODY:DOOR
11
4injuries
SERVICE BRAKES, HYDRAULIC
10
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
9
2injuries
ENGINE AND ENGINE COOLING:ENGINE
8
Total complaints284
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The contact owns a 2002 chevrolet venture. The contact stated that while the vehicle was parked, a fuel odor was detected inside the cabin of the vehicle. Additionally, the vehicle was consuming an excessive amount of fuel. The contact's neighbor, an independent mechanic, diagnosed that there was…”
“Blown intake manifold gasket. Vehicle did not have an overheating issue, and has been well maintained since I've owned it. Drove across a steep 7 mile hill, temp gauge started moving above normal. I stopped and let it cool down, motor got to about 245 degrees well before any warning lights were…”
“Suddenly my vehicle had a strong gasoline odor when I walked up on it in the morning I smelled it 3 feet away from my vehicle. It happened just like that all of a sudden. I scheduled my inspection with my mechanic and I told him I suddenly was smelling a strong odor of gas. My mechanic called and…”
“Fuel filler neck cracked where it is attached to the gas tank. Fuel leaking out of neck.”
“Takata recall I was driving and ran off the edge of the road and over corrected myself an hit an embankment head on and my face went into the steering wheel and then was thrown for the van out the back passenger window and the van then landed on my foot before I hit the road due to air bag never…”
“Takata recall I was driving and ran off the edge of the road and over corrected myself an hit an embankment head on and my face went into the steering wheel and then was thrown for the van out the back passenger window and the van then landed on my foot before I hit the road due to air bag never…”
“Something broke inside steering column , rack & pinon. 100% lost control of steering. Vehicle was in motion when attempt to turn.”
“Tl* the contact owns a 2002 chevrolet venture. While driving approximately 5 mph, the steering snapped and disengaged. The vehicle was coasted to the side of the road and was towed to the contact's residence. Based upon the contact's examination, the gear box was fractured. The failure was not…”
Defect investigations
InvestigationPE04064 Opened 2004-09-17 · closed 2004-12-22
POWER-SLIDING DOOR
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2002 Chevrolet Venture as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.