2001 Volvo Vnl Recalls

VOLVO TRUCKS IS RECALLING CERTAIN MODEL YEAR 2001-2006 VNL AND VNM TRUCKS MANUFACTURED WITH A TRW SEALED DRAG LINKS. CERTAIN FACTORS CAN EXIST, WHICH IF LEFT UNTREATED MAY RESULT IN A BALL SOCKET SEPARATION.

BALL SOCKET SEPARATION AT THE DRAG LINK RESULTS IN COMPLETE LOSS OF STEERING, AND THEREFORE CAN RESULT IN A VEHICLE CRASH.

DEALERS WILL INSPECT AND REPAIR THE BALL SOCKET OR THE DRAG LINK AS REQUIRED IF NECESSARY. AS PARTS ARE LIMITED, VOLVO TRUCKS MAILED AN INTERIM OWNER LETTER ON SEPTEMBER 2, 2010. THE SAFETY RECALL BEGAN ON FEBRUARY 14, 2011. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.

IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.

VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. …

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.

IF LEFT UNDETECTED OR CORRECTED IT COULD LEAD TO THE SEPARATION OF THE FIFTH WHEEL TOP PLATE FROM ITS MOUNTING STRUCTURE, POSSIBLY RESULTING IN A CRASH.

DEALERS WILL REPLACE THE BRACKET PINS AND REPAIR INSTRUCTIONS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT JOST INTERNATIONAL AT 616-846-7700 OR BY EMAIL TO [email protected]…

ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.

SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.

DEALERS WILL REPLACE ALL FRONT AXLE HUBS. AN INTERIM NOTICE TO OWNERS WAS MAILED ON JUNE 25, 2003. FINAL OWNER NOTIFICATION BEGAN ON OCTOBER 6, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT…

CERTAIN HEAVY DUTY CLASS 8 TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE TWO TAIL LAMPS, BACK-UP LAMP,AND LICENSE TAG LAMP WERE MOUNTED ON INSUFFICIENTLY RIGID MOUNTS.

IT MAY NOT ALLOW THE DRIVER OF A REARWARD APPROACHING VEHICLE TO HAVE FULL VIEW OF THE LAMPS.

DEALERS WILL ATTACH THE TWO TAIL LAMPS, BACK-UP LAMP, AND THE LICENSE TAP LAMP ON STIFFER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 31, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO…

CERTAIN HEAVY DUTY CLASS 8 VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS", S5.1.6.3, "ANTILOCK POWER FOR TOWED VEHICLES." ELECTRICAL POWER FOR THE TRAILER ANTI-LOCK BRAKING SYSTEM (ABS) CAN BE DISRUPTED WHEN A SWITCH LOCATED ON THE VEHICLE INSTRUMENT PANEL IS…

IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE OF THE TOWED VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.

DEALERS WILL INSTALL A WIRING HARNESS WHICH WILL PROVIDE CONTINUOUS ELECTRICAL POWER TO THE TRAILER ABS WHENEVER THE IGNITION SWITCH IS IN THE ON OR RUN POSITION. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE…

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR WABCO PNEUMATIC ANITLOCK BRAKE SYSTEM (ABS) VALVE PACKAGES, THE ASSEMBLY BOLTS ON THESE VALVE PACKAGES WERE NOT TIGHTENED CORRECTLY.

BOLTS TORQUED BELOW SPECIFICATION WILL NOT RELIABLY PREVENT AIR LEAKAGE AT THE AFFECTED ABS VALVE PACKAGE INTERFACE JOINTS ONCE THE COMPONENT BEGINS NORMAL VEHICLE OPERATION. IF AIR LEAKS DEVELOP AT ANY OF THE ABS VALVE PACKAGE INTERFACE JOINTS, BRAKE SYSTEM PRESSURE REDUCTIONS COULD OCCUR DURING BRAKING OR NORMAL…

DEALERS WILL TIGHTEN THE FASTENERS TO THE PROPER SPECIFICATION. OWNER NOTIFICATION BEGAN FEBRUARY 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 TRUCKS. THE WRONG STEERING COLUMN TO STEERING GEAR SHAFT MAY HAVE BEEN INSTALLED IN THESE VEHICLES. USING THE SHORTER VNM STEERING SHAFT COULD RESULT IN STEERING SHAFT BEING OPERATED (STEERING COLUMN EXTENDED ADJUSTMENT) OUTSIDE THE NORMAL OPERATING RANGE OF THE STEERING…

OVER TIME THIS CONDITION COULD RESULT IN ACCELERATED WEAR IN THE SHAFT WITH THE POTENTIAL FOR LOSS OF STEERING AS A RESULT.

DEALERS WILL INSTALL THE CORRECT LOWER STEERING SHAFT. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.