The 2009 Chevrolet Malibu has 5 NHTSA recall campaigns affecting an estimated 4,516,747 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 2,356 complaints with NHTSA, most often about the steering. Last updated July 5, 2026.
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and…
Consequence
Any of the above failure conditions increases the risk of a crash.
Remedy
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers…
STEERING14V1530002014-03-311,373,177 affected
Defect
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS)…
Consequence
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model…
POWER TRAIN12V4600002012-09-18426,240 affected
Defect
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
Consequence
If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle…
Remedy
GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may…
POWER TRAIN09V0730002009-03-06276,729 affected
Defect
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND…
Consequence
THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy
DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438,…
VISIBILITY08V6340002008-12-0277 affected
Defect
GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE…
Consequence
IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy
DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Complaints by component
STEERING
764
13crashes1fires3injuries
ELECTRICAL SYSTEM
359
5crashes4fires2injuries
ELECTRONIC STABILITY CONTROL (ESC)
255
5crashes1fires3injuries
EXTERIOR LIGHTING
154
1fires
SERVICE BRAKES
142
3crashes5injuries2deaths
POWER TRAIN
103
VEHICLE SPEED CONTROL
71
AIR BAGS
61
22crashes35injuries3deaths
ENGINE
61
1crashes1fires1injuries
LATCHES/LOCKS/LINKAGES
54
1fires
Total complaints2,356
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The power steering motor failed ,esc , traction and power steeringg lights came on, I am a woman and coould not control the car and my safety and others was at risk for an accident or crash ,there was nothing prior to this just suddenly loosing control of my car and a very scary position to be in…”
“Power steering went out”
“Power steering went out”
“I was cruise control 80mph and my.power steering went out. Esc power steering warning on dash. Car is incredibly hard to steer. When I turn car off and back on it might go away for a few minutes but then come.back randomly in a scary scenarios. Thing is a death trap.”
“The contact owns a 2009 chevrolet malibu. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. Additionally, the traction and power steering assist motor warning lights were illuminated. The vehicle was taken to an independent…”
“Odometer fraud. The contact owns a 2009 chevrolet malibu. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was approximately 120,000 however, the contact researched and discovered in a carfax report that the…”
“The contact owns a 2009 chevrolet malibu. The contact stated that while the vehicle was idling, it lost power steering functionality. The contact pulled over to the side of the road and restarted the vehicle, and the power steering functionality returned. The failure reoccurred every mile while…”
“The contact owns a 2009 chevrolet malibu. The contact stated that while the vehicle was idling, it lost power steering functionality. The contact pulled over to the side of the road and restarted the vehicle, and the power steering functionality returned. The failure reoccurred every mile while…”
Defect investigations
InvestigationAQ10001 Opened 2010-11-18 · closed 2015-12-28
Fleet Vehicle Recall Completion Audit
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2009 Chevrolet Malibu as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.