The 2021 Volvo V60cc has 3 NHTSA recall campaigns affecting an estimated 22,106 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 4 complaints with NHTSA, most often about the air bags. Last updated July 5, 2026.
Recall campaigns
STEERING23V0010002023-01-0574 affected
Defect
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Consequence
A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy
Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
SEAT BELTS21V6820002021-09-0119,149 affected
Defect
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply…
Consequence
An unsecured child restraint system can increase the risk of injury during a crash.
Remedy
Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
AIR BAGS21V0010002021-01-072,883 affected
Defect
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Consequence
A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
Remedy
Volvo Car will notify owners, and dealers will inspect and, as necessary, tighten the SRS control unit mounting screws, free of charge. The recall began February 12, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10068.
Complaints by component
AIR BAGS
1
SERVICE BRAKES
1
UNKNOWN OR OTHER
1
VEHICLE SPEED CONTROL
1
Total complaints4
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Concern: volvo cars’ sunroofs are negligently designed, allowing sunroof drain obstructions to flood the vehicle’s internal electronics. This results in catastrophic and simultaneous system failures, including brake loss, airbag failure, and disabled traction control—posing an extreme and…”
“Concern: volvo cars’ sunroofs are negligently designed, allowing sunroof drain obstructions to flood the vehicle’s internal electronics. This results in catastrophic and simultaneous system failures, including brake loss, airbag failure, and disabled traction control—posing an extreme and…”
“Concern: volvo cars’ sunroofs are negligently designed, allowing sunroof drain obstructions to flood the vehicle’s internal electronics. This results in catastrophic and simultaneous system failures, including brake loss, airbag failure, and disabled traction control—posing an extreme and…”
“Rear tires tread started shredding off particularly on the outside edge. The passenger rear tire is bald on outside edge the driver side is bad but not as extreme.this only took 1,500 miles I don’t know the cause but with 150 miles to get home I switched the drive mode from comfort to eco and…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2021 Volvo V60cc as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.