The 2007 Toyota Tacoma has 10 NHTSA recall campaigns affecting an estimated 6,456,693 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 676 complaints with NHTSA, most often about the suspension. Last updated July 5, 2026.
Recall campaigns
SEATS16V3960002016-06-027,749 affected
Defect
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and…
Consequence
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
SEATS14V7430002014-11-193,233 affected
Defect
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may…
Consequence
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
SUSPENSION14V6040002014-09-29710,711 affected
Defect
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf…
Consequence
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy
Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
SEAT BELTS13V3370002013-08-07342,451 affected
Defect
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the…
Consequence
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy
Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services…
AIR BAGS12V0920002012-03-07495,470 affected
Defect
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERÂ’S AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE…
Consequence
IN THE EVENT OF A CRASH, THE DRIVERÂ’S SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
EQUIPMENT10V0360002010-02-03153,418 affected
Defect
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
EQUIPMENT10V0350002010-02-03271,417 affected
Defect
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION…
Consequence
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS…
EQUIPMENT09V2230002009-06-1527,080 affected
Defect
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
POWER TRAIN07V3240002007-07-26108 affected
Defect
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH FOUR WHEEL DRIVE, A SECTION OF THE REAR PROPELLER SHAFT MAY HAVE BEEN IMPROPERLY CAST.
Consequence
THE FRONT SIDE OF THE REAR PROPELLER SHAFT COULD SEPARATE AT THE JOINT AND COME INTO CONTACT WITH THE ROAD SURFACE WHICH COULD RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE POSSIBILITY OF A CRASH.
Remedy
DEALERS WILL REPLACE THE REAR PROPELLER SHAFT WITH A NEW ONE FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Complaints by component
SUSPENSION
107
1crashes
VEHICLE SPEED CONTROL
95
33crashes1fires12injuries2deaths
STRUCTURE:BODY
85
2crashes
STEERING
54
4crashes1injuries
POWER TRAIN
43
4crashes3injuries
AIR BAGS
39
10crashes7injuries
UNKNOWN OR OTHER
34
2crashes1fires1injuries
SERVICE BRAKES
19
4crashes1injuries
ELECTRICAL SYSTEM
17
3crashes3fires2injuries
SERVICE BRAKES, HYDRAULIC
13
6crashes2fires4injuries
Total complaints676
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Low miles 78000 in 2017 at 51000 miles toyta opted not to replacetbe frame and only treated it with crc now it is rusted out bad and unsafe to drive”
“I have a well cared for, garaged 2007 tacoma. It had a recall for a known frame corrosion issue. I had it inspected by toyota and they chose not to replace the frame, choosing instead to apply a crc spray in 2016. I have learned that my vehicle was sprayed by a formula that was later known to…”
“Single car accident resulting in rollover. Concerns about no airbag deployment”
“My 2007 toyota tacoma has an open recall on the rear leaf springs due to the risk of fuel tank puncture and fire. However, toyota and their authorized dealership are unable to perform this safety recall because the vehicle’s frame is too severely rusted. The dealership informed me that…”
“My 2007 toyota tacoma has an open recall on the rear leaf springs due to the risk of fuel tank puncture and fire. However, toyota and their authorized dealership are unable to perform this safety recall because the vehicle’s frame is too severely rusted. The dealership informed me that…”
“It was determined by the toyota dealer where this vehicle was purchased that there are rust holes in the frame. This vehicle's mileage is less than 100,000 miles. I understand there was a recall at one time however the toyota dealership advised that this truck was not one of the vehicles in the…”
“Purchased my 2 tacoma in 11/24 second party learned of leaf spring tested and failed sent me home in rent a car demanding it back 2 min upon my arrival home due to the frame was damaged. Said they put it up on lift but didn't it was too dangerous. Had to he my vehicle out of their shop saturday…”
“Purchased my 2 tacoma in 11/24 second party learned of leaf spring tested and failed sent me home in rent a car demanding it back 2 min upon my arrival home due to the frame was damaged. Said they put it up on lift but didn't it was too dangerous. Had to he my vehicle out of their shop saturday…”
Defect investigations
InvestigationDP08001 Opened 2008-01-31 · closed 2008-08-27
SUDDEN AND UNCONTROLLED ACCELERATION
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED…
InvestigationDP08001 Opened 2008-01-31 · closed 2008-08-27
SUDDEN AND UNCONTROLLED ACCELERATION
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED…
InvestigationDP08001 Opened 2008-01-31 · closed 2008-08-27
SUDDEN AND UNCONTROLLED ACCELERATION
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2007 Toyota Tacoma as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.