The 2006 Toyota Tacoma has 11 NHTSA recall campaigns affecting an estimated 6,468,738 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 977 complaints with NHTSA, most often about the structure. Last updated July 5, 2026.
Recall campaigns
SEATS16V3960002016-06-027,749 affected
Defect
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and…
Consequence
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
SEATS14V7430002014-11-193,233 affected
Defect
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may…
Consequence
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
SUSPENSION14V6040002014-09-29710,711 affected
Defect
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf…
Consequence
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy
Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
SEAT BELTS13V3370002013-08-07342,451 affected
Defect
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the…
Consequence
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy
Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services…
AIR BAGS12V0920002012-03-07495,470 affected
Defect
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERÂ’S AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE…
Consequence
IN THE EVENT OF A CRASH, THE DRIVERÂ’S SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
EQUIPMENT10V0360002010-02-03153,418 affected
Defect
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
EQUIPMENT10V0350002010-02-03271,417 affected
Defect
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION…
Consequence
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS…
EQUIPMENT09V2230002009-06-1527,080 affected
Defect
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
AIR BAGS06V0960002006-04-03133 affected
Defect
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION…
Consequence
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy
DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
TIRES06V0610002006-03-0212,020 affected
Defect
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence
IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy
DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Complaints by component
STRUCTURE:BODY
148
2crashes1fires3injuries
SUSPENSION
142
1crashes2injuries
VEHICLE SPEED CONTROL
128
44crashes18injuries
AIR BAGS
67
7crashes4injuries
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
52
UNKNOWN OR OTHER
47
4crashes2injuries
STEERING
39
2crashes5injuries
STRUCTURE
25
1crashes1injuries
STRUCTURE:FRAME AND MEMBERS
24
1injuries
POWER TRAIN
23
Total complaints977
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Voss toyota would not perform the recall of new leaf springs that has not been completed on my truck. The frame is rusty and they will not touch my truck. There should be an existing recall or customer satisfaction program on the frame of this truck that needs done as well.”
“The frame of my 2006 toyota tacoma (vin: [xxx] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in…”
“The frame of my 2006 toyota tacoma (vin: [xxx] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in…”
“The frame of my 2006 toyota tacoma (vin: [xxx] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in…”
“The contact owns a 2006 toyota tacoma. The contact stated while driving at an undisclosed speed, the contact heard a loud noise coming from the rear of the vehicle with no warning light illuminated. The contact stated that while the vehicle was parked, the contact noticed that the rear subframe of…”
“The contact owns a 2006 toyota tacoma. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the…”
“The truck's frame has severely rusted. The frame has deteriorated. It is unsafe to drive as the frame is breaking in half. According to toyota, this was a huge problem with the 2006 tacoma. They will not fix the frame or offer any solution. My son can not safely drive this vehicle.”
“The truck's frame has severely rusted. The frame has deteriorated. It is unsafe to drive as the frame is breaking in half. According to toyota, this was a huge problem with the 2006 tacoma. They will not fix the frame or offer any solution. My son can not safely drive this vehicle.”
Defect investigations
InvestigationDP08001 Opened 2008-01-31 · closed 2008-08-27
SUDDEN AND UNCONTROLLED ACCELERATION
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED…
InvestigationDP08001 Opened 2008-01-31 · closed 2008-08-27
SUDDEN AND UNCONTROLLED ACCELERATION
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED…
InvestigationDP08001 Opened 2008-01-31 · closed 2008-08-27
SUDDEN AND UNCONTROLLED ACCELERATION
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2006 Toyota Tacoma as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.