The 2022 Thor Motor Coach Windsport has 1 NHTSA recall campaign affecting an estimated 148 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 7 complaints with NHTSA, most often about the unknown or other. Last updated July 5, 2026.
Recall campaigns
STRUCTURE22V0760002022-02-10148 affected
Defect
Thor Motor Coach (TMC) is recalling certain 2022 ACE, Freedom Traveler, Hurricane, and Windsport motorhomes. The rear ladder may have been installed on the wrong side of the motorhome.
Consequence
An incorrectly installed ladder may break while in use, increasing the risk of injury.
Remedy
Dealers will inspect the location of the rear ladder, and reinforce or relocate the ladder as needed, free of charge. Owner notification letters were mailed March 24, 2022. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000255.
Complaints by component
UNKNOWN OR OTHER
3
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS:LINES AND FITTINGS
1
STRUCTURE
1
STRUCTURE:BODY
1
VISIBILITY/WIPER
1
Total complaints7
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“I’m concerned about the bbq propane compartment getting hairline cracks and the brass shut off valve that’s made of brass and dropping down to the road and getting road rash till it grinds through the shut off valve. I just read on a thor facebook forum that this happened to a 2016 thor…”
“I’m concerned about the bbq propane compartment getting hairline cracks and the brass shut off valve that’s made of brass and dropping down to the road and getting road rash till it grinds through the shut off valve. I just read on a thor facebook forum that this happened to a 2016 thor…”
“While driving on a crowded freeway a wooden structure fell from the ceiling of my motorhome and landed on the dashboard inches from my steering wheel. If it had hit my steering wheel or my hands, I would have been involved in a multiple vehicle collision. Thank god, I was able to safely pull over…”
“While driving on a crowded freeway a wooden structure fell from the ceiling of my motorhome and landed on the dashboard inches from my steering wheel. If it had hit my steering wheel or my hands, I would have been involved in a multiple vehicle collision. Thank god, I was able to safely pull over…”
“The contact owns a 2022 thor motor coach windsport rv built on a 2020 ford f-53 chassis. The contact stated that while driving at 65 mph, a wooden beam used to deflect airflow from the outer venting fell from the ceiling of the rv. The heavy beam fell inches away from the contact's hands that were…”
“The propane heater on our motorhome has been cycling on the high limit switch since new. This is due to insufficient airflow across the heat exchanger. It is also the source of intermittent carbon monoxide alarms being activated. We have had this unsuccessfully repaired under warranty. The cycling…”
“Main propane heater in my thor windsport 29m motorhome was coming on and goings on off before the desired temperature was reached. I realized it was cycling on the high limit switch, which is.generally caused by insufficient air flow over the heat exchanger. Took it in for warranty service which…”
Defect investigations
InvestigationPE24023 Opened 2024-08-14 · closed 2026-01-16
Trailer Hitch Receiver Structure May Crack and Separate
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation, PE24023, on August 14, 2024, to investigate allegations of Thor Motor Coach motorhome frame or trailer hitch structure cracking and separating. The hitch was manufactured by Lippert and installed by Thor as standard original equipment. ODI…
InvestigationPE24023 Opened 2024-08-14 · closed 2026-01-16
Trailer Hitch Receiver Structure May Crack and Separate
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation, PE24023, on August 14, 2024, to investigate allegations of Thor Motor Coach motorhome frame or trailer hitch structure cracking and separating. The hitch was manufactured by Lippert and installed by Thor as standard original equipment. ODI…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2022 Thor Motor Coach Windsport as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.