2023 Thomas Built Saf-T-Liner Hdx Recalls

Recalls on record Updated July 2026

The 2023 Thomas Built Saf-T-Liner Hdx has 8 NHTSA recall campaigns affecting an estimated 26,725 vehicles. Recall repairs are always free at any authorized dealer. Last updated July 5, 2026.

Recall campaigns

ENGINE AND ENGINE COOLING 26V087000 2026-02-13 52 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2025 Saf-T-Liner EFX and 2023-2026 Saf-T-Liner HDX vehicles. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.

Consequence

Contact with hot heating coolant may burn occupants, increasing the risk of injury.

Remedy

Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is F1030.

ENGINE AND ENGINE COOLING 26V086000 2026-02-13 2,843 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2026 Saf-T-Liner EFX and Saf-T-Liner HDX school buses. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.

Consequence

Contact with hot heating coolant may burn occupants, increasing the risk of injury.

Remedy

Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is F1030.

STRUCTURE 22V762000 2022-10-12 17,613 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain 2011-2023 Thomas Built EFX and HDX school buses. The exterior roof panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body…

Consequence

A school bus exterior roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.

Remedy

Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL957.

STRUCTURE 22V688000 2022-09-14 1,259 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain 2020-2023 Thomas Built Saf-T-Liner HDX school buses. The rear exterior side-body panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221,…

Consequence

A school bus panel with insufficient joint strength may separate during a crash, increasing the risk of injury.

Remedy

Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed November 11, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall FL953.

ENGINE AND ENGINE COOLING 22V553000 2022-07-29 71 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain 2023 Thomas Built Saf-T-Liner HDX and Saf-T-Liner C2 school buses. The engine control module (ECM) may experience an internal short-circuit, which can result in an unexpected engine shut down.

Consequence

Unexpected engine shut down can increase the risk of a crash. Additionally, a disabled school bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.

Remedy

Cummins will replace the ECM, free of charge. Owner notification letters are expected to be mailed September 26, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-949.

SEATS 22V510000 2022-07-19 1,806 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain 2014-23 Thomas Built Buses HDX and 2014-22 EFX school buses equipped with 39-inch S3C seat frames and 3-point flex seatbelts. The passenger seat frames may crack and rotate from fatigue.

Consequence

Cracked passenger seat frames may not adequately secure passengers in the event of a crash, increasing the risk of injury.

Remedy

Dealers will secure the seat frames with brackets, free of charge. Owner notification letters were mail December 4, 2023. Owners may contact DTNA's customer service at 1-800-547-0712. DTNA's number for this recall is FL946.

ELECTRICAL SYSTEM 22V271000 2022-04-22 2,943 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain 2019-2023 Thomas Built Bus HDX school buses. The positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit.

Consequence

An electrical short circuit can increase the risk of a fire.

Remedy

Dealers will inspect and repair the cable routing, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL928.

ELECTRICAL SYSTEM 22V272000 2022-04-22 138 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain 2019-2023 Thomas Built Bus HDX commercial buses. The positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit.

Consequence

An electrical short circuit can increase the risk of a fire.

Remedy

Dealers will inspect and repair the cable routing, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL929.

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2023 Thomas Built Saf-T-Liner Hdx as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.