1999 Prevost H3-45 Vip Recalls

ON CERTAIN MOTOR COACHES AND MOTOR HOMES, THE STEERING COLUMNS MAY BE MISSING THE LOWER BOLT AND NUT. A REPLACEMENT BOLT AND NUT WAS INSTALLED TO CORRECT THIS SITUATION ON THE PRODUCTION LINE. IF A REPLACEMENT BOLT HAS BEEN USED AND NOT TIGHTENED PROPERLY, THE COLUMN MAY COME OUT OF THE INPUT SHAFT WHEN THE…

IN SUCH A CASE, A LOSS OF STEERING WOULD OCCUR.

DEALERS WILL VERIFY THE SIZE OF THE BOLT AND NUT AND REPLACE THEM IF NEEDED. OWNER NOTIFICATION BEGAN APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PREVOST AT 1-418-831-5432.

VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.

WITHOUT FUSING, THE EQUALIZER MAY MELT, BURN, OR SMOKE, POSSIBLY RESULTING IN A FIRE OR A SMOKE FILLED BUS, THUS NECESSITATING A PASSENGER EVACUATION OF THE BUS. THE FAILURE MODE CAN CAUSE OPERATOR DISTRACTION, AND/OR POSSIBLE PERSONAL INJURY.

PREVOST WILL NOTIFY OWNERS TO INSPECT THEIR BUSES FOR CERTAIN EQUALIZERS BY THE DATE CODE. THE AFFECTED EQUALIZERS WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 29, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A…

VEHICLE DESCRIPTION: TRANSIT BUSES AND BUS SHELLS. SOME VEHICLES ARE FITTING WITH A STEERING COLUMN ADJUSTMENT PLATE.

THIS COULD LEAD TO LOSS OF VEHICLE CONTROL.

DEALERS WILL INSPECT THE VEHICLES FOR AN ADJUSTMENT PLATE AND WILL REPLACE THE ADJUSTMENT PLATE IF NECESSARY.

VEHICLE DESCRIPTION: TRANSIT BUSES AND BUS SHELLS. SOME BRAKE LINE HOSES MAY HAVE BEEN MANUFACTURED USING HEATER HOSE MATERIAL INSTEAD OF BRAKE LINE HOSE MATERIAL. HEATER HOSES ARE NOT APPROPRIATE FOR USE AS BRAKE LINES BECAUSE THE OPERATING PRESSURE OF THE BRAKING SYSTEM IS MUCH HIGHER THAN THAT OF THE HEATING…

THIS COULD RESULT IN SUDDEN BRAKE LINE FAILURE.

DEALERS WILL REPLACE THE HEATER HOSES WITH CORRECT BRAKE LINE HOSES.

VEHICLE DESCRIPTION: BUS SHELLS. THE HEIGHT CONTROL VALVE LEVER ATTACHED TO THE RADIUS ROD OF THE INDEPENDENT FRONT SUSPENSION MAY HAVE BEEN FASTENED WITHOUT USING LOCK WASHERS.

THE LEVER CAN LOOSEN OVER TIME RESULTING IN IMPROPER SUSPENSION HEIGHT ADJUSTMENT, AND POSSIBLE LOSS OF VEHICLE CONTROL.

DEALERS WILL INSTALL TWO LOCK WASHERS ON THE U-BOLT RETAINING THE HEIGHT CONTROL VALVE LEVER.