The 1990 Plymouth Voyager has 3 NHTSA recall campaigns affecting an estimated 1,274,100 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 270 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.
INBOARD FRONT SEAT BELT BUCKLE ASSEMBLY STRAPS CAN SUFFER FATIGUE FAILURE OF THE STRAP NEAR ITS ANCHOR POSITION.
FATIGUE FAILURE OF SAFETY BELTS IN A SUDDEN STOP ORACCIDENT CONDITION RESULTS IN INCREASED LIKELIHOOD OF INJURY TO SEAT OCCUPANT.
REPLACE FATIGUED STRAPS OR RETROFIT STRAPS WITH A REINFORCEMENT PLATE AND REMOVAL OF AN ANTIROTATION TAB TO PREVENT FATIGUE FAILURE.
INCORRECT SCREWS MAY HAVE BEEN USED IN INSTALLING THE LOAD SENSING BRAKE PROPORTIONING VALVE TO ITS BRACKET CAUSING THE CLAMPING LOAD TO BE LESS THAN INTENDED.
THIS COULD RESULT IN INCONSISTENT FRONT TO REAR BRAKEBALANCE WITH POTENTIAL FOR REAR BRAKE SKID UNDER HEAVY BRAKING CONDITIONS.
REPLACE PROPORTIONING VALVE TO BRACKET SCREWS WITH PROPER LENGTH SCREWS.
THE ENGINE VALVE COVER GASKET MAY DISLOCATE AND ALLOW AN ENGINE OIL LEAK AT THE GASKET.
THE LEAKAGE OF OIL IN THE ENGINE COMPARTMENT COULD CAUSEA FIRE.
REPLACE GASKET COVER WITH REVISED COVER, AND RTV SEALANT WILL BE APPLIED IN PLACE OF A GASKET.
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“Rear left tire is crooked going down road. Found rear axle housing rusted through and kinked. *tr”
“Consumer stated the lift gate latch would not shut.*yh”
“Consumer stated the lift gate latch would not shut.*yh”
“Vehicle was parked in off position for 15 minutes. Upon returning to vehicle, vehicle engine compartment was on fire. *ak”
“Major tire separation - tread came right off at 20 mph! Defectifve tire - still have it!*ak (dot number: 413 022566 tiresize: p205/70r)”
“Tire treads are separating.*ak”
“This will be our 6th transmission. Replacement only this time chrysler refuses to provide a warranty for replacement transmission. *ak”
“While driving about 70 mph right rear tire had a blowout, and a tread separation . But, consumer kept control of vehicle. Cooper tire, p205/70sr15. *ak”
There is no summary currently available
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM…
There is no summary currently available
There is no summary currently available
There is no summary currently available
There is no summary currently available
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1990 Plymouth Voyager as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.