How many recalls does the 2019 Motiv F-59 Bev Chassis have?

The 2019 Motiv F-59 Bev Chassis has 4 NHTSA safety recall campaigns on record.

How do I check if my 2019 Motiv F-59 Bev Chassis has an open recall?

Enter your 17-character VIN at NHTSA's official recall lookup (nhtsa.gov/recalls) to see open, unrepaired recalls for your specific vehicle. Recall repairs are free.

2019 Motiv F-59 Bev Chassis Recalls

Recalls on record Updated July 2026

The 2019 Motiv F-59 Bev Chassis has 4 NHTSA recall campaigns affecting an estimated 712 vehicles. Recall repairs are always free at any authorized dealer. Last updated July 5, 2026.

Recall campaigns

ELECTRICAL SYSTEM 25V261000 2025-04-18 139 affected

Defect

Motiv Power Systems, Inc. (Motiv) is recalling certain 2019-2022 F-53 and F-59 vehicles equipped with a Motiv Gen 5 EPIC powertrain. A support bracket may fatigue and break, allowing the main power disconnect to contact other structures and short.

Consequence

An electrical short can shut down the high voltage system, resulting in a loss of drive power and increasing the risk of a crash.

Remedy

Motiv field support technicians will replace the bracket, free of charge. Owner notification letters were mailed June 9, 2025. Owners may contact Motiv customer service at 1-650-458-4804.

VEHICLE SPEED CONTROL 25V137000 2025-03-03 222 affected

Defect

Motiv Power Systems, Inc. (Motiv) is recalling certain 2017-2020 E-450 and F-59 vehicles with Gen 4 EPIC powertrain, 2020-2023 E-450, F-59, and F-53 vehicles with a Gen 5 EPIC powertrain, and 2023-2025 Motiv F-59 and F-53 vehicles with a Gen 6 EPIC powertrain. A throttle position sensor (TPS) power wire connector…

Consequence

Loss of drive power increases the risk of a crash.

Remedy

Motiv field support technicians will inspect and repair, or replace the PCM connector, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Motiv customer service at 1-650-458-4804.

ELECTRICAL SYSTEM 24V698000 2024-09-19 151 affected

Defect

Motiv Power Systems, Inc. (Motiv) is recalling certain 2017-2020 E-450 and F-59 vehicles equipped with a Motiv Gen 4 EPIC and 2020-2023 F-53 and F-59 vehicles equipped with a Motiv Gen 5 EPIC powertrain. The wiring harness may be missing a heat shrink insulator and retention clip. The 12-volt control wires may…

Consequence

A loss of drive power increases the risk of a crash.

Remedy

Motiv field support technicians will inspect and correct any loose wiring, and replace damaged 12-volt control wires, free of charge. Owner notification letters were mailed November 21, 2024. Owners may contact Motiv customer service at 1-650-458-4804.

ELECTRICAL SYSTEM 24V546000 2024-07-22 200 affected

Defect

Motiv Power Systems, Inc. (Motiv) is recalling certain 2021-2024 E-450, 2019-2023 F-59, and 2019-2020 F-53 vehicles equipped with a Motiv Gen 5 EPIC powertrain. The vehicle control software could misclassify a loss of isolation between the chassis and high voltage system, shutting down the high voltage (HV) batteries.

Consequence

The shutdown of the HV batteries can cause a loss of power steering, brake power assist, and drive power, increasing the risk of a crash.

Remedy

Motiv will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 5, 2024. Owners may contact Motiv customer service at 1-650-458-4804.

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2019 Motiv F-59 Bev Chassis as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.