RecallRepo

2003 GMC Yukon Xl Recalls

Recalls on record Updated July 2026

The 2003 GMC Yukon Xl has 3 NHTSA recall campaigns affecting an estimated 74,716 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 115 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

SERVICE BRAKES, HYDRAULIC 04V045000 2004-02-04 68,875 affected
Defect

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Consequence

CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Remedy

DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

STRUCTURE 03V037000 2003-02-06 107 affected
Defect

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.

Consequence

AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.

Remedy

DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE…

FUEL SYSTEM, GASOLINE 03V019000 2003-01-27 5,734 affected
Defect

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, VEHICLES, DURING A 30 DEGREE LEFT ANGLE FRONTAL IMPACT OF SUFFICIENT SEVERITY, A TEAR COULD DEVELOP IN THE MID-FRAME CROSS MEMBER AT ITS ATTACHMENT TO THE LEFT FRAME RAIL. IF THE MID-FRAME CROSS MEMBER TEARS DURING FRONTAL IMPACT AND PRODUCES A SHARP EDGE, CONTACT…

Consequence

FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy

DEALERS WILL INSTALL A FUEL TANK SHIELD. OWNER NOTIFICATION BEGAN FEBRUARY 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Complaints by component

ELECTRICAL SYSTEM
19
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
17
1crashes1injuries
SERVICE BRAKES
16
1crashes1injuries
STEERING
4
TIRES
4
ENGINE AND ENGINE COOLING
3
1injuries
EQUIPMENT:APPLIANCE:AIR CONDITIONER
3
SERVICE BRAKES, HYDRAULIC
3
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
3
TIRES:TREAD/BELT
3
Total complaints115

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Odometer fraud. The contact purchased a 2003 gmc yukon xl. It was later discovered that there was a mileage discrepancy. The vehicle was a dealer sale on january 26th, 2026. At the time of purchase and at the time of the vehicle registration, the vehicle mileage was 186,000. While applying for…”

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER · reported 2026-02-20

“Headlights as well as daytime running lights do not come on highbeams do however”

ELECTRICAL SYSTEM · reported 2020-02-21

“Headlights as well as daytime running lights do not come on highbeams do however”

EXTERIOR LIGHTING · reported 2020-02-21

“Brake failure due to leak from rusted out brake line under driver seat area and loss of brake fluid.”

SERVICE BRAKES · reported 2019-10-06

“Concerned about the service notice on my dic with the auto ride suspension system. P0660 code detection. No indication of what the condition of the system is inoperable and if the vehicle is in a safe mode until repairs or replacement of parts are made.currently the vehicle has locked the air ride…”

SUSPENSION · reported 2019-10-01

“Tl* the contact owns a 2003 gmc yukon xl. While driving 35 mph, the stability control failed and the vehicle lost power. The stability control active warning indicator illuminated. The vehicle was not diagnosed or repaired. The contact mentioned that there was also a grinding sound. The…”

ELECTRONIC STABILITY CONTROL (ESC) · reported 2016-10-27

“The brakes failed while driving on a city street causing my vehicle to nearly strike a number of children at a crosswalk. After examination by a mechanic, it was determined that the brake line had corroded and burst under pressure. I have received no notice of this potential failure from gmc even…”

SERVICE BRAKES · reported 2016-09-28

“Tl* the contact owns a 2003 gmc yukon xl. The contact stated that when the key chain was attached to the keys, the vehicle failed to start however, when the key chain was removed, the vehicle start as designed. The vehicle was not taken to a dealer nor an independent mechanic for diagnostic…”

ELECTRICAL SYSTEM · reported 2016-07-13

Defect investigations

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation EA04011 Opened 2004-04-09 · closed 2005-05-10

PARKING BRAKE FAILURE

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL…

Investigation EA04011 Opened 2004-04-09 · closed 2005-05-10

PARKING BRAKE FAILURE

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL…

Investigation EA04011 Opened 2004-04-09 · closed 2005-05-10

PARKING BRAKE FAILURE

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL…

Investigation EA04011 Opened 2004-04-09 · closed 2005-05-10

PARKING BRAKE FAILURE

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2003 GMC Yukon Xl as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.