RecallRepo

2002 GMC Envoy Recalls

Recalls on record Updated July 2026

The 2002 GMC Envoy has 13 NHTSA recall campaigns affecting an estimated 3,793,788 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 626 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.

Recall campaigns

ENGINE AND ENGINE COOLING 04V289000 2004-06-23 29,951 affected
Defect

SOME SPORT UTILITY VEHICLES EQUIPPED WITH AN ELECTRONICALLY CONTROLLED AIR SUSPENSION (ECAS) HAVE A CONDITION IN WHICH THE ECAS MAY PRODUCE A BRIEF ELECTRICAL SPIKE WHILE THE VEHICLE IS OPERATING. THIS ELECTRICAL SPIKE CAN DISRUPT THE POWERTRAIN CONTROL MODULE (PCM) CAUSING THE VEHICLE TO STALL.

Consequence

IF THE SPIKE DAMAGES THE PCM, THE VEHICLE MAY NOT RESTART. IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.

Remedy

DEALERS WILL INSTALL A WIRING HARNESS. THE RECALL WILL BEGIN ON AUGUST 19, 2004. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537 OR GMC AT 1-866-996-9463.

SEAT BELTS 04V201000 2004-04-28 261,801 affected
Defect

CERTAIN LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." ONE OF THE TWO SENSORS IN THE DRIVER'S AND FRONT PASSENGER'S SEAT BELT RETRACTORS COULD BE INOPERATIVE. THE SEAT BELT RETRACTORS WILL LOCK WHEN THE BELT WEBBING IS…

Consequence

IF THIS WERE TO OCCUR, THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, AND COULD RESULT IN INJURY TO THE OCCUPANT.

Remedy

DEALERS WILL INSPECT THE DRIVER AND FRONT PASSENGER SAFETY BELT RETRACTORS, AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 24, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537.

VISIBILITY 04V046000 2004-02-04 581,394 affected
Defect

CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT…

Consequence

DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438;…

EQUIPMENT 03V250000 2003-07-15 1,707,825 affected
Defect

CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

Consequence

THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy

OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT…

ELECTRICAL SYSTEM 03V096000 2003-03-19 314,300 affected
Defect

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION" AND NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE AN INTERMITTENT CONDITION DURING VEHICLE START-UP IN WHICH THE INSTRUMENT PANEL…

Consequence

THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.

Remedy

DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER. OWNER NOTIFICATION BEGAN MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR…

POWER TRAIN 03V075000 2003-03-06 511,167 affected
Defect

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE…

Consequence

THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.

Remedy

DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT…

STRUCTURE 02V273000 2002-10-04 46 affected
Defect

CERTAIN SPORT UTILITY VEHICLES ARE MISSING WELDS ON THE REAR FLOOR PLAN.

Consequence

IN A CRASH, MISSING WELDS COULD DEGRADE PERFORMANCE OF THE THIRD ROW SEAT AND SAFETY BELT ANCHORAGE AND OCCUPANTS COULD RECEIVE GREATER INJURIES.

Remedy

DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF MISSING WELDS ARE FOUND, GM WILL EXCHANGE THE VEHICLE FOR AN EQUIVALENT VEHICLE OR PROVIDE A REFUND OF THE PURCHASE PRICE. OWNER NOTIFICATION BEGAN OCTOBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT…

FUEL SYSTEM, GASOLINE 02V121000 2002-08-23 136,511 affected
Defect

ON CERTAIN SPORT UTILITY VEHICLES, A FUEL FILTER FITTING CAN BECOME DISCONNECTED. IF THIS WERE TO OCCUR WHILE ATTEMPTING TO START THE ENGINE, A NO-START CONDITION WOULD RESULT AND FUEL WOULD BE PUMPED OUT THE FUEL FILTER ONTO THE GROUND.

Consequence

IF THE FITTING BECOMES DISCONNECTED WHILE THE VEHICLE IS IN MOTION, THE ENGINE WOULD STOP DUE TO INADEQUATE FUEL SUPPLY AND CAUSE A LOSS OF POWER STEERING ASSIST. IF AN IGNITION SOURCE WERE PRESENT, FUEL LEAKAGE FROM A DISCONNECTED FUEL FILTER FITTING COULD RESULT IN A FIRE.

Remedy

DEALERS WILL REPLACE THE FUEL FILTER QUICK CONNECT RETAINERS. OWNER NOTIFICATION BEGAN SEPTEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. GMC AT…

AIR BAGS 02V222000 2002-08-09 133,221 affected
Defect

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence

PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy

DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT…

POWER TRAIN 01V334000 2001-10-17 78,004 affected
Defect

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT.

Consequence

IF THE GEAR IS NOT ENGAGED, THE VEHICLE CAN ROLL WHEN THE TRANSMISSION IS IN "PARK" AND A CRASH COULD RESULT WITHOUT WARNING.

Remedy

DEALERS WILL UPDATE THE TRANSFER CASE CONTROL MODULE CALIBRATION TO INCREASE GEAR ENGAGEMENT. OWNER NOTIFICATION BEGAN NOVEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT…

POWER TRAIN 01V283000 2001-09-05 895 affected
Defect

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES (4 WHEEL-DRIVE). SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.

Consequence

THIS CONDITION COULD RESULT IN A COMPLETE FRACTURE OF THE RANGE SHIFT COLLAR AND SUBSEQUENT LOSS OF VEHICLE FORWARD AND REVERSE GEARS, AND THE INABILITY TO MAINTAIN "PARK" POSITION. THIS INCREASES THE RISK OF A VEHICLE CRASH RESULTING FROM UNINTENDED MOVEMENT OF A PARKED VEHICLE.

Remedy

DEALERS WILL REPLACE THE TRANSFER CASES AND UPDATE THE CONTROL MODULE CALIBRATION. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT…

STRUCTURE 01V158000 2001-05-16 8,197 affected
Defect

VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS." THESE VEHICLES HAVE A CONSOLE COVER/ARMREST LID LATCH THAT COULD RELEASE AT LESS THAN THE 10G VERTICAL LOAD REQUIREMENT OF THE STANDARD.

Consequence

IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.

Remedy

DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM AND INSTALL A STRIKER PLATE. OWNER NOTIFICATION BEGAN JULY 16, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GMC AT 1-800-462-8782.

SUSPENSION 01V126000 2001-04-12 30,476 affected
Defect

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME.

Consequence

A SEPARATION COULD RESULT IN LOSS OF VEHICLE CONTROL, RESULTING IN A CRASH.

Remedy

DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CONTROL ARM BRACKETS. OWNER NOTIFICATION BEGAN BY TELEPHONE ON APRIL 4, 2001. THE FOLLOWUP LETTER TO CONSUMERS WAS MAILED MAY 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY…

Complaints by component

POWER TRAIN:AUTOMATIC TRANSMISSION
49
1crashes2fires2injuries
ELECTRICAL SYSTEM
46
1crashes4fires
AIR BAGS
26
19crashes24injuries2deaths
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
25
ENGINE AND ENGINE COOLING
24
2fires
ENGINE AND ENGINE COOLING:ENGINE
20
FUEL/PROPULSION SYSTEM
18
VISIBILITY:REARVIEW MIRRORS/DEVICES
17
1crashes
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
16
1crashes
ENGINE
15
1fires
Total complaints626

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“These vehicles have a rampant and long-standing reputation for developing leaks in their plastic fuel tanks. Virtually all of these vehicles eventually develop leaks, which cause release of flammable fuel vapors and raw gasolene releases. Why isn't there a recall on these faulty fuel tanks? The…”

FUEL/PROPULSION SYSTEM · reported 2025-09-17

“My vehicle has developed a leak in the plastic fuel tank at the junction of the fill hose connection and the body of the tank that is causing release of flammable vapors and liquid gasoline underneath the vehicle and causing failure of emissions systems. These vehicles have a rampant and…”

FUEL/PROPULSION SYSTEM · reported 2025-09-17

“Went to store bought food left store and car started chugging and losing power when I got home my son said he could smell exhaust and it sounds like the catalytic converter”

UNKNOWN OR OTHER · reported 2025-07-09

“Passenger front seat belt locks automatically as soon as you buckle up. It will not unlock, the only way to fix it is to unbuckle and re buckle then it locks again. Very uncomfortable to ride in the front passenger seat.”

SEAT BELTS · reported 2022-08-02

“The contact owns a 2002 gmc envoy. The contact stated that while driving at an undisclosed speed, the vehicle was shaking. Upon inspection, the contact noticed that the rear subframe had fractured and detached. The vehicle was taken to an independent mechanic who diagnosed that the subframe needed…”

STRUCTURE · reported 2022-01-01

“The contact owns a 2002 gmc envoy. The contact stated that while driving at an undisclosed speed, the vehicle was shaking. Upon inspection, the contact noticed that the rear subframe had fractured and detached. The vehicle was taken to an independent mechanic who diagnosed that the subframe needed…”

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT · reported 2022-01-01

“There are previously fixed recalls starting to pop up one at a time if they were fixed they wouldnt be back causing problems can someone check into this and let me know something I drive a 02 gmc envoy slt 4x4 4.2l. The mileage is unknown due to instrument cluster not working on the dic settings.I…”

FUEL/PROPULSION SYSTEM · reported 2021-04-19

“There are previously fixed recalls starting to pop up one at a time if they were fixed they wouldnt be back causing problems can someone check into this and let me know something I drive a 02 gmc envoy slt 4x4 4.2l. The mileage is unknown due to instrument cluster not working on the dic settings.I…”

EXTERIOR LIGHTING · reported 2021-04-19

Defect investigations

Investigation EA03007 Opened 2003-05-06 · closed 2004-06-18

ENGINE STALL

MODEL YEAR (MY) 2002 BRAVADA AND CERTAIN MY 2002 ENVOY VEHICLES WITH OPTIONAL ELECTRONICALLY CONTROLLED AIR SUSPENSION (ECAS) MAY BE SUBJECT TO ENGINE STALL CAUSED BY AN ERRANT VOLTAGE SPIKE TRANSMITTED TO THE POWERTRAIN CONTROL MODULE (PCM).IN ADDITION TO ENGINE STALL, IF THE SPIKE DAMAGES THE PCM, THE VEHICLE MAY…

Investigation EA04002 Opened 2004-01-06 · closed 2004-02-10

WINDSHIELD WIPER FAILURE

ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS…

Investigation EA04002 Opened 2004-01-06 · closed 2004-02-10

WINDSHIELD WIPER FAILURE

ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS…

Investigation EA04002 Opened 2004-01-06 · closed 2004-02-10

WINDSHIELD WIPER FAILURE

ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS…

Investigation EA04002 Opened 2004-01-06 · closed 2004-02-10

WINDSHIELD WIPER FAILURE

ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS…

Investigation EA04021 Opened 2004-08-03 · closed 2004-11-04

BRAKE LAMP FAILURE

GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE…

Investigation EA07009 Opened 2007-07-10 · closed 2008-08-28

FUEL PUMP MODULE LEAKS GASOLINE

DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF…

Investigation PE02036 Opened 2002-03-18 · closed 2002-10-03

PINCHER/CHAFED WIRING

Investigation PE02093 Opened 2002-12-17 · closed 2003-04-09

2002 TRAILBLAZER/ENVOY FUEL TANK LEAKS

SEE ATTACHED REPORT.

Investigation PE02093 Opened 2002-12-17 · closed 2003-04-09

2002 TRAILBLAZER/ENVOY FUEL TANK LEAKS

SEE ATTACHED REPORT.

Investigation PE03001 Opened 2003-01-03 · closed 2003-05-06

ENGINE STALL

OF THE 697 TOTAL COMPLAINTS, 240 WERE RECEIVED FOR THEENVOY AND 457 FOR THE BRAVADA.GM HAS IDENTIFIED ABOUT 5,000 WARRANTY CLAIMS RELATED TO STALLING IN THE SUBJECT VEHICLES.GM REPORTS THAT A TRANSIENT VOLTAGE SPIKE GENERATED IN THE ECAS DEGRADES THE PERFORMANCE OF THE PCM RESULTING IN ENGINE STALL.GM MODIFIED THE…

Investigation PE03001 Opened 2003-01-03 · closed 2003-05-06

ENGINE STALL

OF THE 697 TOTAL COMPLAINTS, 240 WERE RECEIVED FOR THEENVOY AND 457 FOR THE BRAVADA.GM HAS IDENTIFIED ABOUT 5,000 WARRANTY CLAIMS RELATED TO STALLING IN THE SUBJECT VEHICLES.GM REPORTS THAT A TRANSIENT VOLTAGE SPIKE GENERATED IN THE ECAS DEGRADES THE PERFORMANCE OF THE PCM RESULTING IN ENGINE STALL.GM MODIFIED THE…

Investigation PE03001 Opened 2003-01-03 · closed 2003-05-06

ENGINE STALL

OF THE 697 TOTAL COMPLAINTS, 240 WERE RECEIVED FOR THEENVOY AND 457 FOR THE BRAVADA.GM HAS IDENTIFIED ABOUT 5,000 WARRANTY CLAIMS RELATED TO STALLING IN THE SUBJECT VEHICLES.GM REPORTS THAT A TRANSIENT VOLTAGE SPIKE GENERATED IN THE ECAS DEGRADES THE PERFORMANCE OF THE PCM RESULTING IN ENGINE STALL.GM MODIFIED THE…

Investigation PE03042 Opened 2003-09-17 · closed 2004-01-06

WINDSHIELD WIPER FAILURE

THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE…

Investigation PE03042 Opened 2003-09-17 · closed 2004-01-06

WINDSHIELD WIPER FAILURE

THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE…

Investigation PE07013 Opened 2007-03-12 · closed 2007-07-10

FUEL PUMP MODULE LEAKS GASOLINE

ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI…

Investigation RQ08001 Opened 2008-02-28 · closed 2008-07-09

HAZARD LIGHT SWITCH FAILURE

ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION…

Investigation RQ08001 Opened 2008-02-28 · closed 2008-07-09

HAZARD LIGHT SWITCH FAILURE

ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION…

Investigation RQ17002 Opened 2017-04-24 · closed 2021-03-29

Loss of Headlights

The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2002 GMC Envoy as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.