The 2020 Ford Ranger has 7 NHTSA recall campaigns affecting an estimated 1,049,562 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 148 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT25V6850002025-10-1059,006 affected
Defect
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit…
Consequence
An electrical short circuit can increase the risk of a fire.
Remedy
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters,…
BACK OVER PREVENTION25V4420002025-06-27200,237 affected
Defect
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport,…
Consequence
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
EQUIPMENT23V3790002023-05-2629,607 affected
Defect
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements…
Consequence
An overloaded vehicle increases the risk of a crash.
Remedy
Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at…
SEAT BELTS21V8110002021-10-1547,683 affected
Defect
Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers…
Consequence
A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy
Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect…
CHILD SEAT21V7650002021-09-3037,625 affected
Defect
Ford Motor Company (Ford) is recalling certain 2020-2021 Ranger Super Cab vehicles equipped with rear seats containing fixed head restraints. The fixed head restraints may interfere with proper installation of certain types of child seats. Additionally, the child seat may not attach properly to the lower-rear…
Consequence
An improperly attached child seat can increase the risk of injury in a crash.
Remedy
Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification…
BACK OVER PREVENTION20V5750002020-09-23620,246 affected
Defect
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As…
Consequence
Reduced rearward visibility can increase the risk of a crash.
Remedy
Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this…
POWER TRAIN20V1970002020-04-0355,158 affected
Defect
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different…
Consequence
If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy
Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Complaints by component
POWER TRAIN
42
ENGINE
14
UNKNOWN OR OTHER
13
ELECTRICAL SYSTEM
11
SERVICE BRAKES
9
3crashes4injuries
EXTERIOR LIGHTING
6
STRUCTURE:BODY
5
VEHICLE SPEED CONTROL
5
1crashes
FORWARD COLLISION AVOIDANCE: WARNINGS
4
2crashes
SEAT BELTS
4
Total complaints148
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Transmission is awful jerky, jumps in and out of gear, causing engine rpm’s to go really high. Shifts erratically, causing me to almost rear end other vehicles. Very dangerous situations a many occasions. Won’t accelerate at times when pulling out in to traffic, causing other drivers to slow…”
“Truck was shifting weird the day before incident got really bad. The next day on the way home from my newborns dr appointment it began shuddering really badly and would make a loud thud noise when shifting so I had to pull off to the side of the road. There was never a warning lamp or message…”
“In may of 2025, the transmision of my 2020 ford ranger with 35,000 miles jolted and bucked expectadly at traffic lights, I had full loss of engagement of the transmission several times, engine would rev to 4000rpm and no transmission enagement. These issues happened while at traffic stops and…”
“The contact owns a 2020 ford ranger. The contact stated that while driving, at an undisclosed speed, the vehicle began to shift hard when downshifting and upshifting. The vehicle jerked. The vehicle went into limp mode. There was a reduction of power. No warning lights illuminated. The vehicle was…”
“Clicking sound coming from under the dash. I traced it to the blend door assy. Defrost intermittently will disengage. Vehicle has 29,600 miles on it”
“Bought 2020 ford ranger lariat in march 2024 with 13k miles. I have had no issues and have kept up maintenance needed. Vehicle currently has 19,128 miles and on 4/17/26 while driving the vehicle lost power. I was able to pull over and immediately called the dealership where vehicle was purchased…”
“Bought 2020 ford ranger lariat in march 2024 with 13k miles. I have had no issues and have kept up maintenance needed. Vehicle currently has 19,128 miles and on 4/17/26 while driving the vehicle lost power. I was able to pull over and immediately called the dealership where vehicle was purchased…”
“Bought 2020 ford ranger lariat in march 2024 with 13k miles. I have had no issues and have kept up maintenance needed. Vehicle currently has 19,128 miles and on 4/17/26 while driving the vehicle lost power. I was able to pull over and immediately called the dealership where vehicle was purchased…”
Defect investigations
InvestigationRQ21002 Opened 2021-08-03 · open
Rearview Camera FMVSS 111 Noncompliance
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2020 Ford Ranger as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.