RecallRepo

2019 Ford F-350 Recalls

Recalls on record Updated July 2026

The 2019 Ford F-350 has 4 NHTSA recall campaigns affecting an estimated 1,087,633 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 721 complaints with NHTSA, most often about the steering. Last updated July 5, 2026.

Recall campaigns

POWER TRAIN 20V576000 2020-09-23 9,628 affected
Defect

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350, single rear wheel and dual rear wheel, 4X4 vehicles. The front axles may contain a wheel end yoke that was not properly welded to the axle tube end.

Consequence

An improperly welded axle may affect vehicle control, increasing the risk of a crash.

Remedy

Ford will notify owners and dealers will inspect the front axle wheel yoke weld location. If the weld is found to be inaccurately located, the axle assembly will be replaced free of charge. The recall began October 16, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall…

POWER TRAIN 19V688000 2019-09-30 28,579 affected
Defect

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350 vehicles equipped with electronically locking rear differentials. The passenger side rear axle shaft may fail prematurely due to a material issue.

Consequence

A broken passenger side rear axle could result in a loss of drive power and the inability to hold the vehicle still when in Park. If the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of a crash.

Remedy

Ford will notify owners, and dealers will inspect the passenger side rear axle shaft, replacing it as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S31.

SEATS 19V633000 2019-08-28 639,137 affected
Defect

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are…

Consequence

A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy

Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

ENGINE 18V894000 2018-12-18 410,289 affected
Defect

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and…

Consequence

When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

Remedy

Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

Complaints by component

STEERING
264
2crashes3injuries
SUSPENSION
211
3crashes1injuries
UNKNOWN OR OTHER
40
3crashes2fires2injuries
WHEELS
36
1crashes
STRUCTURE:BODY
20
2crashes
ENGINE
16
1fires1injuries
BACK OVER PREVENTION
15
ELECTRICAL SYSTEM
15
2crashes
FUEL/PROPULSION SYSTEM
13
2fires1injuries
POWER TRAIN
9
Total complaints721

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“This model has the same bosh cp4 high pressure fuel pump as the recalled models 2020-2022 and in fact being older the catastrophic failure risk is higher due to additional mileage. If this part fails the engine shuts off with loss of steering and braking even when pulling 15-20k pounds. The safety…”

FUEL/PROPULSION SYSTEM · reported 2026-06-24

“My rearview camera is showing a distorted image and then goes blank while in reverse creating a safety issue while backing up. The camera is doing everything listed in the following recall campaigns: 20c19/22v252 20c19/24v188 20c19/20v575 but ford says my truck does not qualify for the recall…”

BACK OVER PREVENTION: WARNINGS · reported 2026-03-23

“I have about 54000 miles on a 2019 ford super duty 350 with the power stroke 6.7. Engine light went on and its at willowbrook ford in illinois. Emission problem with particular sensor code 22e02. The cost of repair is between $816 plus another $1259 if it is cracked. This is absolutely ridiculous.…”

ENGINE · reported 2026-01-23

“A steering control module in my steering wheel failed which makes the lane keeping warning not operate correctly and the steering wheel not straight it's set at an angle to the right so when you're driving down the road you have to have it constantly turn to the right a little bit in order to go…”

STEERING · reported 2026-01-20

“A steering control module in my steering wheel failed which makes the lane keeping warning not operate correctly and the steering wheel not straight it's set at an angle to the right so when you're driving down the road you have to have it constantly turn to the right a little bit in order to go…”

LANE DEPARTURE: WARNING · reported 2026-01-20

“Failed component was the upper fuel filter/ fuel filter connecting lines located on top of the 6.7 power stroke engine broke and poured diesel all over the engine and into the valley causing the engine and engine bay to catch on fire while driving down the road. Safety was the fact that our entire…”

FUEL/PROPULSION SYSTEM · reported 2026-01-01

“While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, it soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then…”

FUEL/PROPULSION SYSTEM · reported 2025-11-30

“While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, it soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then…”

ENGINE · reported 2025-11-30

Defect investigations

Investigation PE18011 Opened 2018-10-12 · closed 2019-12-12

Power tailgate opens unintended

By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints…

Investigation PE18011 Opened 2018-10-12 · closed 2019-12-12

Power tailgate opens unintended

By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints…

Investigation PE24014 Opened 2024-05-09 · open

Sogefi Secondary Diesel Fuel Filter Leak

The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe…

Investigation PE24014 Opened 2024-05-09 · open

Sogefi Secondary Diesel Fuel Filter Leak

The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe…

Investigation RQ21001 Opened 2021-01-15 · closed 2024-01-10

Power Tailgate Release Systems

In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in…

Investigation RQ21001 Opened 2021-01-15 · closed 2024-01-10

Power Tailgate Release Systems

In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in…

Investigation RQ21001 Opened 2021-01-15 · closed 2024-01-10

Power Tailgate Release Systems

In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2019 Ford F-350 as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.