The 2002 Country Coach Intrigue has 5 NHTSA recall campaigns affecting an estimated 3,773 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 10 complaints with NHTSA, most often about the unknown or other. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT07V0310002007-02-012,406 affected
Defect
CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy
COUNTRY COACH WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). A SECONDARY BURNER HOUSING WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2007. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COUNTRY COACH AT 1-800-452-8015.
EQUIPMENT03V1090002003-03-26485 affected
Defect
ON CERTAIN MOTORHOMES EQUIPPED WITH INTERNATIONAL THERMAL RESEARCH (ITR)HURRICANE HOT WATER HEATERS, THE ELECTRONIC CONTROL BOARD MAY ADVERSELY AFFECT SAFETY FEATURES IN SOME OF THE SYSTEMS PROTECTING AGAINST OVERHEATING AND POTENTIAL FIRE SITUATION.
Consequence
IF THE SAFETY FEATURES DO NOT SHUT DOWN PROPERLY, THE HEATING SYSTEM CAN CONTINUE HEATING, POSSIBLY RESULTING IN A FIRE.
Remedy
THE DEFECTIVE ELECTRONIC CONTROL BOARD WILL BE REPLACED. IN THE MEANTIME, CUSTOMERS SHOULD TURN THE SYSTEM OFF USING THE MASTER ON/OFF SWITCH LOCATED ON THE SIDE OF THE ELECTRONIC CONTROL BOX WHICH IS ADJACENT TO THE HEATER. OWNERS WHO TAKE THEIR MOTORHOMES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND…
VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Consequence
IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.
VISIBILITY01V3580002001-11-2321 affected
Defect
VEHICLE DESCRIPTION: MOTOR HOMES. THE WINDSHIELD WIPERS EQUIPPED WITH THE SMARTWHEEL OPTION WERE IMPROPERLY GROUNDED. THE IMPROPER GROUND CAUSES THE WIPER MOTORS AND BLADES TO PERIODICALLY STOP WHEN THE MOTOR HOME IS IN TRANSIT AT FREEWAY SPEEDS.
Consequence
FAILURE OF THE WINDSHIELD WIPER MOTORS TO WORK COULD LEAD TO LOSS OF VISIBILITY DURING CRITICAL PERIODS WHEN WIPERS ARE NECESSARY, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL CORRECTLY GROUND THE WINDSHIELD WIPER MOTOR CASE. OWNER NOTIFICATION BEGAN DECEMBER 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.
SERVICE BRAKES, AIR01V1110022001-06-26667 affected
Defect
VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH CUMMINS ISC AND ISL DIESEL ENGINES. THE INTERNAL FRONT BUSHING CAN SPIN, CAUSING DAMAGE TO THE AIR COMPRESSOR, AND POSSIBLY TO THE SPINDLE DRIVE AT THE REAR FACE OF THE AIR COMPRESSOR WHICH IS USED TO PROVIDE POWER TO THE VEHICLE HYDRAULIC PUMP. FAILURE OF THE AIR…
Consequence
WITHOUT POWER ASSIST, THE VEHICLE BECOMES VERY DIFFICULT TO TURN AND COULD POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy
CUMMINS WILL NOTIFY COUNTRY COACH CUSTOMERS AND REPLACE THE AIR COMPRESSOR FREE OF CHARGE. OWNER NOTIFICATION BEGAN MARCH 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CUMMINS CUSTOMER…
Complaints by component
UNKNOWN OR OTHER
3
ELECTRICAL SYSTEM
1
ELECTRICAL SYSTEM:WIRING
1
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
1
EQUIPMENT
1
FUEL SYSTEM, OTHER
1
STRUCTURE:BODY:DOOR
1
TIRES
1
Total complaints10
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“I purchased used a 40' class a motorhome from dealer in tuscon, az.. Before picking it up, I inquired from the service manager the date of the tires manufacture. The tires were 8 years old. I asked that he replace those old 12r22.5 tires with new tires at my expense. When I picked up the coach in…”
“The electric steps extended while the vehicle was in motion. The dealer replaced the computer. *nlm”
“While driving the carbon monoxide alarm activated due the carbon monoxide produced by the refrigerator. The dealer inspected the vehicle but could not duplicated or correct the problem. *nlm”
“Odi id number : 10018204 is incorrect and no paperwork has arrived for me to sign or edit- this is a life threatening condition that puts all drivers and nearby cars etc. At risk. Complant should read:while driving the carbon monoxide alarm activated due the carbon monoxide in the coach produced…”
“Odi id number : 10018204 is incorrect and no paperwork has arrived for me to sign or edit- this is a life threatening condition that puts all drivers and nearby cars etc. At risk. Complant should read:while driving the carbon monoxide alarm activated due the carbon monoxide in the coach produced…”
“Odi id number : 10018204 is incorrect and no paperwork has arrived for me to sign or edit- this is a life threatening condition that puts all drivers and nearby cars etc. At risk. Complant should read:while driving the carbon monoxide alarm activated due the carbon monoxide in the coach produced…”
“Odi id number : 10018204 is incorrect and no paperwork has arrived for me to sign or edit- this is a life threatening condition that puts all drivers and nearby cars etc. At risk. Complant should read:while driving the carbon monoxide alarm activated due the carbon monoxide in the coach produced…”
“This complaint called in as odi id number: 10018202. Complaint "the electric steps extended while the vehicle was in motion. The dealer replaced the computer."additional data: 1st event, 2 weeks after delivery, may 2002. Random opening of the steps while driving in reno on street, step out light…”
Defect investigations
InvestigationSQ01013 Opened 2001-11-23 · closed 2001-12-13
INOPERATIVE WINDSHIELD WIPERS
ALLEGED THAT THE SINDSHIELD WIPER SYSTEM FAILS DUE TO AN IMPROPERLY GROUNDED ELECTRICAL CIRCUIT.THIS CONDITION COULD RESULT IN INOPERATIVE WINDSHIELD WIPERS WITH NO ADVANCE WARNING.
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2002 Country Coach Intrigue as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.