The 1996 Country Coach Intrigue has 5 NHTSA recall campaigns affecting an estimated 1,904 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 2 complaints with NHTSA, most often about the tires. Last updated July 5, 2026.
COUNTRY COACH HAS REPORTED THAT THE TOYO 275/70R M102Z TIRES ON CERTAIN MOTOR HOMES ARE DEFECTIVE AND COULD FAIL UNEXPECTEDLY.
THIS COULD CAUSE A LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THESE TIRES WITH MICHELIN 275/70R XZA2 TIRES. THE FEDERAL TIRE LABELS WILL ALSO BE REPLACED. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE MOTOR HOMES WERE ERRONEOUSLY ASSIGNED INADEQUATE COLD TIRE INFLATION PRESSURES AND INADEQUATE AXLE WEIGHT RATINGS ON THE FRONT…
THIS COULD CAUSE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE DURING NORMAL DRIVING. THE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE COULD LEAD TO A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE FRONT AND/OR REAR TIRES. IN SOME INSTANCES, THE MOTOR HOMES MAY ONLY HAVE AN INADEQUATE FAWR AND/OR RAWR STATED ON THE FEDERAL TIRE LABEL AND ONLY THE FEDERAL TIRE LABEL WILL BE REPLACED. OWNER NOTIFICATION IS EXPECTED TO BEGIN AUGUST 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN…
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE VEHICLES HAVE AN INEQUITABLE WEIGHT DISTRIBUTION BETWEEN THE FRONT LEFT AND RIGHT TIRES ON THE FRONT AXLE. THIS WEIGHT INEQUITY CAN CAUSE THE LEFT FRONT TIRE WEIGHT…
THIS COULD CAUSE PREMATURE FRONT TIRE TREAD WEAR OR TIRE FAILURE DURING NORMAL DRIVING. THE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE COULD LEAD TO A LOSS OF STEERING CONTROL.
DEALERS WILL REPLACE THE HEIGHT CONTROL VALVES AND THE HEIGHT CONTROL VALVE CONFIGURATION REVERSED TO REMEDY THIS NONCOMPLIANCE. OWNER NOTIFICATION BEGAN MAY 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME…
VEHICLE DESCRIPTION: MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THESE VEHICLES WERE ASSIGNED AN INADEQUATE FRONT AXLE WEIGHT RATING (FAWR). AS A CONSEQUENCE, THE FRONT BRAKE CANISTERS AND SLACK ADJUSTERS DO NOT COMPLY WITH THE STANDARD REQUIREMENTS.
THIS COULD CAUSE INCREASED STOPPING DISTANCES DURING BRAKING, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE FRONT BRAKE CANISTERS AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION BEGAN MARCH 15, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.
THE "O" RINGS OF THE REGULATOR ASSEMBLY IN THE ONAN EMERALD AND MARQUIS BRAND GENERATOR SETS CAN WEAKEN AND BREAK WHEN EXPOSED TO HIGH AMBIENT TEMPERATURES.
IF AN IGNITION SOURCE IS PRESENT, LIQUID PROPANE GAS (LPG) LEAKAGE COULD RESULT IN A FIRE.
OWNER NOTIFICATION WILL BE CONDUCTED BY ONAN. DEALERS WILL EITHER REMOVE THE LPG REGULATOR AND REPLACE IT WITH A MODEL NOT SUBJECT TO RUPTURE, OR INSTALL A PRE-REGULATOR IN THE FUEL SYSTEM.
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“Tl* the contact owns a 1996 country coach intrigue equipped with goodyear g159 tires, size: 265/75/r22.5 (na). While driving approximately 60 mph, there was a loud noise coming from the rear of the vehicle. The vehicle was stopped and the contact noticed that the rear passenger side inner dual…”
“Front left tire blew out while driving at 65 mph. A boat was being towed at the time of the blow out. This occurred after the fmvss120/weight distributor recall 01v170000 was performed.*ak”
ON JUNE 30, 2006, COUNTRY COACH FILED DEFECT REPORT 06V-262 STATING THAT THE TOYO 275/70R22.5M102Z TIRES ARE DEFECTIVE AND COULD FAIL UNEXPECTEDLY CAUSING A LOSS OF VEHICLE CONTROL.ODI'S INVESTIGATION FOUND THAT FRONT TIRE FAILURES HAVE BEEN CAUSED BY COUNTRY COACH'S SELECTION OF TIRES THAT PROVIDED MARGINAL LOAD…
ODI IS UPGRADING THIS RECALL QUERY (RQ) AND OPENING AN ENGINEERING ANALYSIS (EA05-011).COUNTRY COACH HAS IDENTIFIED 21 INCIDENTS OF FRONT TIRE FAILURES (16 DRIVER'S SIDE AND 5 PASSENGER SIDE) THAT HAVE OCCURRED IN MODEL YEAR 1995-2000 COUNTRY COACH INTRIGUE AND ALLURE VEHICLES AFTER THESE VEHICLES HAD BEEN MODIFIED…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1996 Country Coach Intrigue as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.