The 2016 Chevrolet Tahoe has 8 NHTSA recall campaigns affecting an estimated 7,819,907 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 346 complaints with NHTSA, most often about the service brakes. Last updated July 5, 2026.
Recall campaigns
POWER TRAIN26V2890002026-05-0766 affected
Defect
General Motors, LLC (GM) is recalling certain 2026 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles with four-wheel (4WD) or all-wheel drive (AWD), and certain 2015-2020 Suburban, Escalade, Escalade ESV, Yukon, Yukon XL, and Tahoe…
Consequence
Front or rear wheel lockup increases the risk of a crash.
Remedy
Owners are advised not to drive their vehicle until the remedy is completed. Dealers will inspect and, if necessary, replace the transfer case assembly, free of charge. Owner notification letters were mailed May 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at…
SEAT BELTS21V2450002021-04-082,568 affected
Defect
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting…
Consequence
A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
SERVICE BRAKES19V7610002019-10-24652,967 affected
Defect
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41…
Consequence
Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
SERVICE BRAKES, HYDRAULIC19V6450002019-09-063,456,719 affected
Defect
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence
As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this…
SEAT BELTS18V2910002018-05-0323,004 affected
Defect
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 1500 and Tahoe Police Pursuit and Special-Service vehicles. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the…
Consequence
If the pretensioner cable becomes fatigued or breaks, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy
GM will notify owners, and dealers will replace the pretensioner cable and seat side-shield, free of charge. The recall began June 19, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18156.
SEAT BELTS17V4370002017-07-1040,683 affected
Defect
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado…
Consequence
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer…
AIR BAGS16V6510002016-09-083,640,162 affected
Defect
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit…
Consequence
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer…
SUSPENSION16V2560002016-04-283,738 affected
Defect
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Silverado 1500 and 2016 Cadillac Escalade, Cadillac Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Sierra, GMC Yukon and GMC Yukon XL vehicles. The front upper control arms may have inadequate welds near the control arm bushing.
Consequence
Inadequate welds may allow the control arm to separate from the bushing, compromising steering and increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will replace the left and right front upper control arms and realign the vehicle, free of charge. The recall began on May 18, 2016. Until the repairs have been made, owners are advised not to drive their vehicles. Owners may contact Chevrolet customer service at 1-800-222-1020,…
Complaints by component
SERVICE BRAKES
84
9crashes5injuries
POWER TRAIN
47
1crashes1fires
UNKNOWN OR OTHER
44
2crashes1injuries
ELECTRICAL SYSTEM
29
STEERING
19
2crashes2injuries
SUSPENSION
19
1injuries
ENGINE
18
FUEL/PROPULSION SYSTEM
14
STRUCTURE:BODY
10
2crashes2injuries
AIR BAGS
9
5crashes7injuries
Total complaints346
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“There is delamination happening on the hood and roof of my car and is putting the integrity of the car at risk with bare metal being exposed to the elements thus causing rust and break down of the structure of the vehicle.”
“I live in lake charles louisiana. I have a 2016 tahoe ltz my transmission went out .”
“I purchased a 2016 chevrolet tahoe on march 8, 2026, in [xxx] . After the sale, I discovered that the vehicle has serious undisclosed safety defects, including evidence that the airbag (supplemental restraint system) had previously deployed and was not properly repaired or restored to working…”
“I purchased a 2016 chevrolet tahoe on march 8, 2026, in [xxx] . After the sale, I discovered that the vehicle has serious undisclosed safety defects, including evidence that the airbag (supplemental restraint system) had previously deployed and was not properly repaired or restored to working…”
“I purchased a 2016 chevrolet tahoe on march 8, 2026, in [xxx] . After the sale, I discovered that the vehicle has serious undisclosed safety defects, including evidence that the airbag (supplemental restraint system) had previously deployed and was not properly repaired or restored to working…”
“At first it started with my brakes. I was at dq and all of a sudden the brake peddle was hard and would barely go down. I then put my car in park. Now I have all new brakes, rotors, etc. Then now the car after 139,000 miles and only owning it for 3 years has this hesitation to go. It stumbles and…”
“At first it started with my brakes. I was at dq and all of a sudden the brake peddle was hard and would barely go down. I then put my car in park. Now I have all new brakes, rotors, etc. Then now the car after 139,000 miles and only owning it for 3 years has this hesitation to go. It stumbles and…”
“At 155,000 miles transmission shudders and slips gears. Torque, converter went out and started slipping more and whining and making a grinding sound. Transmission had to be completely rebuilt, with all six clutches, and a brand new torque converter had to be installed.”
Defect investigations
InvestigationPE18012 Opened 2018-11-20 · closed 2022-04-10
Brake Vacuum Pump Failure
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado…
InvestigationPE18012 Opened 2018-11-20 · closed 2022-04-10
Brake Vacuum Pump Failure
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado…
InvestigationPE18012 Opened 2018-11-20 · closed 2022-04-10
Brake Vacuum Pump Failure
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2016 Chevrolet Tahoe as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.