The 2021 Chevrolet Silverado 3500 has 5 NHTSA recall campaigns affecting an estimated 1,661,656 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 54 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Recall campaigns
POWER TRAIN24V7970002024-10-24463,295 affected
Defect
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels…
Consequence
Rear wheel lock-up can increase the risk of a crash.
Remedy
Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may…
General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while…
Consequence
An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.
Remedy
Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at…
SERVICE BRAKES, HYDRAULIC21V7580002021-09-293,241 affected
Defect
General Motors, LLC (GM) is recalling certain 2021-2022 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles with electronic brake control modules (EBCM) replaced during vehicle assembly. The bolts that attach the brake pressure modulator valve (BPMV) assembly may not be properly…
Consequence
Water in the BPMV may cause an electrical short circuit and increase the risk of fire.
Remedy
Owners are advised to park outside and away from other structures until the recall repair is completed. Dealers will replace the BPMV assembly, free of charge. Owner notification letters were mailed on October 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at…
SEAT BELTS20V8110002020-12-23470 affected
Defect
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used…
Consequence
If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at 1-800-458-8006, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202322230.
SEAT BELTS20V7920002020-12-17624,216 affected
Defect
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row…
Consequence
If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy
GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at…
Complaints by component
ELECTRICAL SYSTEM
11
POWER TRAIN
7
STRUCTURE:BODY
6
1crashes
LATCHES/LOCKS/LINKAGES
5
SERVICE BRAKES
5
UNKNOWN OR OTHER
5
FUEL/PROPULSION SYSTEM
4
ENGINE
3
AIR BAGS
2
EXTERIOR LIGHTING
1
Total complaints54
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Water entered tailgate through drainage hole in tailgate cap. The water then dripped on the tailgate switch causing it to short out. This short circuit caused my tailgate to open and close randomly without pressing any switches or buttons or key fobs. May tailgate has a small ding it it now from…”
“Water entered tailgate through drainage hole in tailgate cap. The water then dripped on the tailgate switch causing it to short out. This short circuit caused my tailgate to open and close randomly without pressing any switches or buttons or key fobs. May tailgate has a small ding it it now from…”
“The tailgate will go up and down when the vehicle is turned off and in park. It will also do this while driving the vehicle. * I notice there has already been a recall for this issue, but my vin shows no recalls”
“My 2021 chevy 3500hd diesel had the engine light come on and the service emissions system popped up in the info screen. It said in so many miles speed would be limited. I took it to the dealer and they said the def tank would need replaced because the tank wiring connector overheated and would…”
“My 2021 chevy 3500hd diesel had the engine light come on and the service emissions system popped up in the info screen. It said in so many miles speed would be limited. I took it to the dealer and they said the def tank would need replaced because the tank wiring connector overheated and would…”
“My 2021 chevy 3500hd diesel had the engine light come on and the service emissions system popped up in the info screen. It said in so many miles speed would be limited. I took it to the dealer and they said the def tank would need replaced because the tank wiring connector overheated and would…”
“Service engine light kept coming on the dash, and the code came back to a faulty def heater. My truck had a reduced power countdown on the dash indicating the truck was going go to into limp mode after x amount of miles. On warmer days the code would go away and there would be no reduced power.…”
“The contact owns a 2021 chevrolet silverado 3500. The contact stated that the tailgate occasionally opened and closed unintendedly. The failure had occurred several times. The dealer was contacted and notified of the failure. The vehicle was not diagnosed or repaired; however, an appointment was…”
Defect investigations
InvestigationPE21010 Opened 2021-04-09 · closed 2023-08-24
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through…
InvestigationPE21010 Opened 2021-04-09 · closed 2023-08-24
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through…
InvestigationPE21010 Opened 2021-04-09 · closed 2023-08-24
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through…
InvestigationPE21010 Opened 2021-04-09 · closed 2023-08-24
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2021 Chevrolet Silverado 3500 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.