The 2020 Chevrolet Silverado 2500 has 10 NHTSA recall campaigns affecting an estimated 2,218,477 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 134 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.
Recall campaigns
POWER TRAIN26V0830002026-02-121,055 affected
Defect
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Consequence
Rear wheel lock up increases the risk of a crash.
Remedy
Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle…
POWER TRAIN24V7970002024-10-24463,295 affected
Defect
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels…
Consequence
Rear wheel lock-up can increase the risk of a crash.
Remedy
Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may…
General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while…
Consequence
An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.
Remedy
Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at…
TIRES21V5780002021-07-2986 affected
Defect
General Motors, LLC. (GM) is recalling certain 2020-2021 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with a 17" spare tire (RPO ZHQ or ZXT) and either the 20" accessory road tire (RPO REM) or the 18" accessory road tire (RPO Q2V). Operating the spare tire with other 20" or 18" tires can prevent…
Consequence
An ABS system that cannot control the rear wheels independently increases the risk of a crash.
Remedy
Dealers will provide the appropriate spare tire and apply a new spare tire information label, free of charge. Owner notification letters were mailed on October 18, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; GMC customer service at 1-800-462-8782. GM's number for this recall is N212329780.
SEAT BELTS20V7920002020-12-17624,216 affected
Defect
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row…
Consequence
If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy
GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at…
POWER TRAIN20V6500002020-10-2242 affected
Defect
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle is moving.
Consequence
If the driveshaft separates, there may be a loss of propulsion, increasing the risk of crash.
Remedy
GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202314870.
AIR BAGS20V4460002020-07-30769 affected
Defect
General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag (RRAB) inflator may not have been properly crimped to the…
Consequence
If the diffuser separates from the inflator during deployment, RRAB performance may be degraded, increasing the risk of injury in a crash.
Remedy
GM will notify owners, and dealers will replace the suspect RRAB modules, free of charge. The recall began September 3, 2020. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-333-4223, or Buick customer service at 1-800-521-7300. GM's number for this recall is…
General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles previously recalled under 20V-142. Some of the vehicles in 20V-324 were not part of Recall 20V-142 but received defect parts during another service (typically during collision repair). The…
Consequence
If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will replace the hood assembly, free of charge. For hoods sold over the counter, dealers will contact customers with instructions for hood replacement. The recall began July 7, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at…
General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The hood-latch striker wires may not have been heat-treated properly, possibly causing them to fracture.
Consequence
If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will replace the hood assembly, free of charge. The recall began April 13, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192284960.
SEAT BELTS19V8140002019-11-14556,399 affected
Defect
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the…
Consequence
A vehicle fire could result if materials ignite inside the vehicle.
Remedy
GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.
Complaints by component
POWER TRAIN
29
1crashes1fires2injuries
ELECTRICAL SYSTEM
15
2fires
SERVICE BRAKES
15
1crashes
ENGINE
10
1fires2injuries
UNKNOWN OR OTHER
10
STEERING
9
FUEL/PROPULSION SYSTEM
8
TIRES:TREAD/BELT
7
STRUCTURE:BODY
6
ENGINE AND ENGINE COOLING
4
Total complaints134
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“I got to my destination and got out of the truck and like a hour later I came back to my truck to get in and my truck was full of smoke and stunk and my center console and center dash melted and gone . Nothing would work . That’s all I know”
“2020 3.0 diesel duramax sucked in the antifreeze and caused a hydrolock. The dealer says that it is not covered under warranty since the engine was over 100k miles. They did offer a new engine for $30k which I declined. The truck was always well taken care of and only received the best in all…”
“My 2020 chevrolet silverado has locked up a couple times on 4/2/26 I immediately drove to the robins chevy dealership, the service writer and I discussed the recall of the transmission, the next day I was sent a estimate of 6800.00 dollars to replace the valve body of the transmission, I asked why…”
“This vehicle does not recognize that the gear is on park. Due to the issue, it has left me stranded twice. The first time it was at a very remote area up in the mountains. I was stuck for hours due to battery dying. The second time being a very dangerous situation because it was a very dangerous…”
“This vehicle does not recognize that the gear is on park. Due to the issue, it has left me stranded twice. The first time it was at a very remote area up in the mountains. I was stuck for hours due to battery dying. The second time being a very dangerous situation because it was a very dangerous…”
“This vehicle does not recognize that the gear is on park. Due to the issue, it has left me stranded twice. The first time it was at a very remote area up in the mountains. I was stuck for hours due to battery dying. The second time being a very dangerous situation because it was a very dangerous…”
“My dash has been displaying intermittently “service electric trailer brakesâ€�. I have recently purchased a 30’ travel trailer. After driving a couple hundred miles with trailer in tow. The code started appearing even with the trailer not connected. I have contacted gm and they have indicated…”
“The contact owns a 2020 chevrolet silverado 2500. The contact stated that while driving at an undisclosed speed, the tailgate opened unexpectedly and was crushed by an attached trailer. The vehicle was taken to a dealer, where it was diagnosed and associated with nhtsa campaign number: 24v060000…”
Defect investigations
InvestigationPE21010 Opened 2021-04-09 · closed 2023-08-24
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through…
InvestigationPE21010 Opened 2021-04-09 · closed 2023-08-24
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through…
InvestigationPE21010 Opened 2021-04-09 · closed 2023-08-24
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through…
InvestigationPE21010 Opened 2021-04-09 · closed 2023-08-24
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2020 Chevrolet Silverado 2500 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.