The 2019 Volvo XC90 has 6 NHTSA recall campaigns affecting an estimated 227,850 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 53 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Recall campaigns
SEAT BELTS23V8270002023-12-072,911 affected
Defect
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Consequence
An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy
Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
STEERING23V0010002023-01-0574 affected
Defect
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Consequence
A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy
Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence
Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy
Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
ELECTRICAL SYSTEM21V2730002021-04-21162 affected
Defect
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Consequence
The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.
Remedy
Volvo Car will notify owners, and dealers will update the rear seat control display software, free of charge. Owner notification letters were mailed July 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10093.
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence
If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy
Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result,…
Consequence
If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy
Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Complaints by component
ELECTRICAL SYSTEM
11
1crashes1fires2injuries
ENGINE
9
1crashes2fires
UNKNOWN OR OTHER
9
2injuries
AIR BAGS
3
SERVICE BRAKES
3
1injuries
STRUCTURE:BODY
2
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
1
1injuries
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
1
ENGINE AND ENGINE COOLING
1
1fires3injuries
FUEL SYSTEM, GASOLINE
1
Total complaints53
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The contact owns a 2019 volvo xc90. The contact stated that while driving at various highway speeds, the vehicle suddenly entered limp mode and decelerated before stalling. The failure had occurred on two separate occasions. On one occasion, the vehicle did not restart and was towed to the dealer.…”
“The suspension module failed due to water accumulation on floorboards. Suspect other electronics may be at risk. Water ingress cause by a combination of what dealer said was a worn out sunroof gasket and two of four drains that became plugged. Further examination from dealer found the plugged…”
“The suspension module failed due to water accumulation on floorboards. Suspect other electronics may be at risk. Water ingress cause by a combination of what dealer said was a worn out sunroof gasket and two of four drains that became plugged. Further examination from dealer found the plugged…”
“The front and rear evaporator core of my 2019 volvo xc90 has failed and I no longer have air conditioning. This issue was diagnosed by a dealer. The evaporator core failure is a massive, widely documented issue specifically targeting the 2016–2020 volvo spa-platform models. According to my…”
“Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about a year or two ago and two back to back a few weeks ago. The first time I was stopped at a drive through but in “driveâ€� with my foot on the brake. All of the sudden the car…”
“Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about a year or two ago and two back to back a few weeks ago. The first time I was stopped at a drive through but in “driveâ€� with my foot on the brake. All of the sudden the car…”
“Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about a year or two ago and two back to back a few weeks ago. The first time I was stopped at a drive through but in “driveâ€� with my foot on the brake. All of the sudden the car…”
“I am writing to formally a repeated mechanical failure involving the hvac evaporator systems in two volvo vehicles that I purchased within a few months of each other. The vehicles involved are: • 2019 volvo xc90 t6 momentum vin: [xxx] purchased: november 2024 • 2020 volvo xc60 t5 momentum…”
Defect investigations
InvestigationDP22005 Opened 2023-01-27 · closed 2023-08-07
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2019 Volvo XC90 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.