The 2020 Volvo XC60 has 6 NHTSA recall campaigns affecting an estimated 301,947 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 28 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence
A short circuit in a high-voltage battery increases the risk of a fire.
Remedy
Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were…
STEERING23V0010002023-01-0574 affected
Defect
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Consequence
A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy
Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
SERVICE BRAKES, HYDRAULIC21V7160002021-09-159 affected
Defect
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Consequence
Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
Remedy
Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence
Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy
Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence
The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy
Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence
If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy
Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The seal on my 2020 volvo xc60 moonroof allowed water to leak under the floorboards. My car is only 6 years old. We had a lot of rain over a short period and I noticed the sound of water sloshing around under the floor. Nothing was wet inside the car. My check engine light came on as well. I took…”
“The seal on my 2020 volvo xc60 moonroof allowed water to leak under the floorboards. My car is only 6 years old. We had a lot of rain over a short period and I noticed the sound of water sloshing around under the floor. Nothing was wet inside the car. My check engine light came on as well. I took…”
“Volvo has failed to repair or compensate me for the nhtsa recall 25v-179. I received a notification of te recall in a letter dated may 14, 2025. I have repeatedly visited the local dealership as well as called volvo customer care. Today, in a conversation with a volvo customer care representative,…”
“Recall identified over a year ago during q1 2025. Manufacturer and dealer have failed to provide appropriate updates for the repair, and no eta has been given for repair. The only direction received from manufacturer and dealer was to not plug in the vehicle until the recall is completed. So as it…”
“Vehicle with 34,000 miles has started to have surging of rotors when applying brakes at 33,000. Vehicle has had brake disc kit replaced due to warping at 13,058 miles. Vehicle had brake disc kits and front and rear brake rotors replaced due to high spots for pad engagement at 22,996 miles. The…”
“The passenger side window spontaneously shattered while we were driving normal speed on the highway. It was not hit by anything, and thankfully no one was hurt, but this concerns us because it makes us worry there's a defect in all the windows and they should be replaced. We also want to make sure…”
“Good morning: I've attached a letter that I've written to volvo usa regarding their security lug bolts on the wheels of their vehicles and the adapter that they provide to remove this. I found out after incurring a flat tire that these adapters are often non-functional and that the dealer is well…”
“Severe oil leak coming from the engine. I had it in the volvo dealership, they claimed it was due to a loose oil filter. When I drove the vehicle home and parked in my driveway, it started to stain the driveway with a fresh oil leak.”
Defect investigations
InvestigationDP22005 Opened 2023-01-27 · closed 2023-08-07
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2020 Volvo XC60 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.