RecallRepo

2004 Volvo Vn Recalls

Recalls on record Updated July 2026

The 2004 Volvo Vn has 4 NHTSA recall campaigns affecting an estimated 63,056 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 1 complaint with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

SEAT BELTS 12V510000 2012-10-18 1,496 affected
Defect

Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of…

Consequence

In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.

Remedy

Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.

VISIBILITY 04V457000 2004-09-17 56,154 affected
Defect

ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.

Consequence

IF THIS OCCURS, EXCESSIVE HEAT AND SMOKE COULD RESULT IN AN UNDER HOOD FIRE.

Remedy

DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

POWER TRAIN 04V405000 2004-08-12 4,032 affected
Defect

ON CERTAIN TRUCKS, THE BOLTS THAT RETAIN THE UNIVERSAL JOINT TO THE YOKE AT THE TRANSMISSION MAY NOT BE TIGHTENED CORRECTLY.

Consequence

THIS CAN RESULT IN THE DRIVE SHAFT COMING LOOSE FROM THE TRANSMISSION, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REMOVE AND INSTALL REMOVING NEW BOLTS, INSPECT FOR CROSS-THREADED BOLTS, AND REPLACE THE YOKE IF NECESSARY. THE RECALL BEGAN OCTOBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

TRAILER HITCHES 04V315000 2004-07-02 1,374 affected
Defect

ON CERTAIN TRUCKS, A MALFUNCTION IN THE SOLENOID VALVE MAY ALLOW AIR TO BE RELEASED TO FIFTH WHEEL LATCH WHEN THE PARK BRAKE IS ENGAGED.

Consequence

THIS CONDITION COULD CAUSE THE FIFTH WHEEL LATCH TO RELEASE INADVERTENTLY WHEN THE PARK BRAKE IS ENGAGED, CREATING THE POTENTIAL FOR LOSS OF THE TRAILER. A CRASH COULD OCCUR WITHOUT PRIOR WARNING.

Remedy

DEALERS WILL ADD AN ADDITIONAL SOLENOID VALVE IN SERIES WITH THE EXISTING PNEUMATIC CIRCUIT FOR THE FIFTH WHEEL AIR RELEASE. THE RECALL BEGAN ON AUGUST 9, 2004. OWNERS SHOULD CONTACT VOLVO AT 1-800-528-6586.

Complaints by component

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
1
Total complaints1

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Dt:history of electrical problems since purchase of semi-truck. When driving at any speeds or even shifting into gear the truck stops without warning. When this occurs the engine dies and loses all electrical power. Several times, the engine stalled for a second and then quit. Consumer had to…”

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS · reported 2003-10-10

Defect investigations

Investigation PE06054 Opened 2006-11-16 · closed 2007-02-07

INOPERABLE TAIL LIGHTS

ODI OPENED THIS INVESTIGATION BASED ON A TECHNICAL SERVICE BULLETIN AND EWR DATA. EWR WARRANTY DATA IS AGGREGATE DATA AND INDIVIDUAL REPORTS ARE NOT SUBMITTED.VOLVO REVIEWED THEIR WARRANTY DATA AND DETERMINED THAT ONLY 63 OF THE EWR WARRANTY CLAIMS RELATED TO THE SUBJECT VEHICLES DISPLAYED SYMPTOMS CONSISTENT WITH…

Investigation PE06054 Opened 2006-11-16 · closed 2007-02-07

INOPERABLE TAIL LIGHTS

ODI OPENED THIS INVESTIGATION BASED ON A TECHNICAL SERVICE BULLETIN AND EWR DATA. EWR WARRANTY DATA IS AGGREGATE DATA AND INDIVIDUAL REPORTS ARE NOT SUBMITTED.VOLVO REVIEWED THEIR WARRANTY DATA AND DETERMINED THAT ONLY 63 OF THE EWR WARRANTY CLAIMS RELATED TO THE SUBJECT VEHICLES DISPLAYED SYMPTOMS CONSISTENT WITH…

Investigation PE06054 Opened 2006-11-16 · closed 2007-02-07

INOPERABLE TAIL LIGHTS

ODI OPENED THIS INVESTIGATION BASED ON A TECHNICAL SERVICE BULLETIN AND EWR DATA. EWR WARRANTY DATA IS AGGREGATE DATA AND INDIVIDUAL REPORTS ARE NOT SUBMITTED.VOLVO REVIEWED THEIR WARRANTY DATA AND DETERMINED THAT ONLY 63 OF THE EWR WARRANTY CLAIMS RELATED TO THE SUBJECT VEHICLES DISPLAYED SYMPTOMS CONSISTENT WITH…

Investigation RQ11001 Opened 2011-05-23 · closed 2012-01-20

Volvo Sleeper glass de-bonding

ODI opened Recall Query RQ11-001 after a review of EWR Field Reports identified lower bunk window separations on the subject vehicles.Volvo had issued three recalls for sleeper window separations since 2003.Additionally, Volvo had issued two bulletins for sleeper window issues during the same time period.The…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2004 Volvo Vn as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.