The 2011 Volvo S40 has 2 NHTSA recall campaigns affecting an estimated 7,427 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 7 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Recall campaigns
STRUCTURE11V1860002011-03-187 affected
Defect
VOLVO IS RECALLING CERTAIN MODEL YEAR 2011 S40 PASSENGER VEHICLES. A CRACK ON THE TOP SIDE OF THE PASSENGER SIDE SUPPORT MEMBER IN THE ENGINE COMPARTMENT MAY HAVE DEVELOPED DURING THE FORMING PROCESS IN COMPONENT PRODUCTION.
Consequence
THE CRACK COULD HAVE AN EFFECT ON THE FRONT STRUCTURE AND MAY REDUCE THE CRASH PERFORMANCE OF THE VEHICLE.
Remedy
DEALERS WILL INSPECT FOR CRACKS ON THE TOP SIDE OF THE PASSENGER SIDE SUPPORT MEMBER IN THE ENGINE COMPARTMENT. IF NO CRACK IS FOUND, NO FURTHER ACTION IS NEEDED. IF THE INSPECTION REVEALS THAT A VEHICLE HAS A CRACK IN THE SIDE SUPPORT MEMBER, THE VEHICLE WILL IMMEDIATELY BE TAKEN OUT OF SERVICE. A NEW REPLACEMENT…
SEATS10V5910002010-11-227,420 affected
Defect
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
Consequence
POSITIONING OF THE SEAT BEYOND THE INTENDED MAXIMUM CAN CAUSE INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.
Remedy
DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT [email protected].
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Odometer fraud. The contact purchased a 2011 volvo s40. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the mileage was 115,314. The contact stated that at the time of registration, it was discovered that the mileage was 350,000 on…”
“Windshield bonding has failed on the top edge of the windshield. It leaks and I can move the glass easily. I am worried that the windshield will fall out in a crash and reduce the airbag performance”
“Driving down the highway at 55 mph when instrument panel went completely blank I heard a sizzling noise behind the dash board. I lost the speedometer, gas gauge, light indicator, blinker indicators, all of the instruments you depend on while driving down the road. I immediately pulled over and…”
“Driving down the highway at 55 mph when instrument panel went completely blank I heard a sizzling noise behind the dash board. I lost the speedometer, gas gauge, light indicator, blinker indicators, all of the instruments you depend on while driving down the road. I immediately pulled over and…”
“Driving down the highway at 55 mph when instrument panel went completely blank I heard a sizzling noise behind the dash board. I lost the speedometer, gas gauge, light indicator, blinker indicators, all of the instruments you depend on while driving down the road. I immediately pulled over and…”
“A cold, wet, wintery morning; pulled into coffee shop parking lot, parked car, turned engine off, removed key, got out of the car, locked doors, went into the coffee shop. The car was stationary, nothing left on in the car. While waiting for coffee glanced out coffee shop window. Saw that the car…”
“Battery dead and car would not start; car had not been used for only 1 week or less. *tr”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2011 Volvo S40 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.