1992 Volvo 960 Recalls
No NHTSA recalls on record for the 1992 Volvo 960. That means NHTSA has no open safety campaign for this vehicle — it does not guarantee the absence of problems. Owners have filed 23 complaints with NHTSA, most often about the engine and engine cooling. Last updated July 5, 2026.
Complaints by component
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“1992 960 stalls while driving. *ts the dealer attempted to remedy the problem. The vehicle continued to stall while driving at high speeds. The vehicle would make a jerking motion before shutting off. The vehicle would also stall while parking. The power windows and door locks malfunctioned. The…”
“1992 960 stalls while driving. *ts the dealer attempted to remedy the problem. The vehicle continued to stall while driving at high speeds. The vehicle would make a jerking motion before shutting off. The vehicle would also stall while parking. The power windows and door locks malfunctioned. The…”
“1992 volvo 960 series stalled while driving at high speeds. The power windows and locks also ceased functioning when the vehicle stalled. *kb the vehicle jerked prior to stalling. The vehicle battery would go dead if parked one day. The vehicle was taken to the dealer twice but they were unable to…”
“After turning the ignition car when up in flames. Volvo claims that the damage was so severe that they could not find a cause. *ak”
“After turning the key smoke came up from under the front hood. In spite of taking the key out the engine continued to make noise. Occasionally the engined stopped, but then started again. Eventually the whole engine compartment when up in flames. I want to report this and found out if this is a…”
“07/11/99 driving the volvo +/-40 mph - not under load - & engine quit - metal on metal noise - pulled off roadway & called a wrecker. Timing belt had broken 1,250 miles short of next change. Called volvo of north america - they stated it was a matter btwn me & dealer who last changed the timing…”
“The timing belt on this vehicle was replaced at 60000 miles service. The service invoice states "replace timing belt and install damper. R/r timing belt and damper as per bulletin" now less than 30,000 miles later the timing belt has broken with estimated repair cost of $ 3000. What is the…”
“The timing belt on this vehicle was replaced at 60000 miles service. The service invoice states "replace timing belt and install damper. R/r timing belt and damper as per bulletin" now less than 30,000 miles later the timing belt has broken with estimated repair cost of $ 3000. What is the…”
Defect investigations
INADVERT. AIR BAG DEPLOYS
There is no summary currently available
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1992 Volvo 960 as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.