RecallRepo

2000 Volkswagen Passat Recalls

Recalls on record Updated July 2026

The 2000 Volkswagen Passat has 3 NHTSA recall campaigns affecting an estimated 969,284 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 625 complaints with NHTSA, most often about the service brakes, hydraulic. Last updated July 5, 2026.

Recall campaigns

FUEL SYSTEM, GASOLINE 08V156000 2008-04-07 412,000 affected
Defect

VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE…

Consequence

A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.

Remedy

DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON…

FUEL SYSTEM, GASOLINE 02V026000 2002-01-25 487,284 affected
Defect

ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.

Consequence

FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.

Remedy

DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR…

FUEL SYSTEM, GASOLINE 01V157000 2001-05-03 70,000 affected
Defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN…

Consequence

RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.

Remedy

DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN…

Complaints by component

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
59
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
56
ELECTRICAL SYSTEM
30
1crashes8fires3injuries
SERVICE BRAKES, HYDRAULIC
27
2injuries
ENGINE AND ENGINE COOLING:ENGINE
25
2fires
SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE
24
STEERING:LINKAGES:TIE ROD ASSEMBLY
19
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
17
SUSPENSION:FRONT:CONTROL ARM
17
1injuries
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
15
Total complaints625

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Side airbag deployed for no reason while driving straight at the speed limit of 75 mph. The local vw dealer determined the side impact sensor is defective. This is a very interesting situation because a fail safe exists in these systems in that the supplemental restraint control module in the…”

AIR BAGS · reported 2025-09-08

“Tl* the contact owns a 2000 volkswagen passat. The contact stated that while attempting to start the vehicle after being parked overnight, he noticed a fuel odor. The contact stated that the fuel tank was half empty after being refilled. The contact took the vehicle to a certified mechanic and was…”

FUEL SYSTEM, GASOLINE · reported 2020-11-12

“Tl* the contact owns a 2000 volkswagen passat. While driving approximately 20 mph, smoke billowed from under the hood of the vehicle. The contact was able to safely leave the roadway, the hood was raised and flames appeared in the engine compartment. The fire department arrived and extinguished…”

ENGINE · reported 2019-07-03

“Tl* the contact owns a 2000 volkswagen passat. While driving approximately 20 mph, smoke billowed from under the hood of the vehicle. The contact was able to safely leave the roadway, the hood was raised and flames appeared in the engine compartment. The fire department arrived and extinguished…”

FUEL/PROPULSION SYSTEM · reported 2019-07-03

“Tl* the contact owns a 2000 volkswagen passat. While driving at any speed, the vehicle would overheat and cause the engine to fail. The contact stated that the failure was recurring and the "emissions work" indicator illuminated sometimes during the failure. The vehicle was taken to an independent…”

ENGINE · reported 2018-04-18

“Tl* the contact owns a 2000 volkswagen passat. While driving at any speed, the vehicle would overheat and cause the engine to fail. The contact stated that the failure was recurring and the "emissions work" indicator illuminated sometimes during the failure. The vehicle was taken to an independent…”

ENGINE AND ENGINE COOLING:COOLING SYSTEM · reported 2018-04-18

“While driving on the highway, we started smelling gasoline in the cabin. We pulled over and checked under the hood. A fuel line attached to the firewall had a leak directly above the exhaust system, and was spraying gasoline everywhere in the engine bay, including the catalytic converter and…”

FUEL/PROPULSION SYSTEM · reported 2017-01-05

“Tl* the contact owns a 2000 volkswagen passat. The contact smelled fuel inside and outside the vehicle. While inspecting the vehicle, the contact discovered fuel leaking under the rear passenger side of the vehicle. The cause of the failure was not diagnosed. The vehicle was not repaired. The…”

FUEL SYSTEM, GASOLINE · reported 2016-08-01

Defect investigations

Investigation DP05004 Opened 2005-08-11 · closed 2005-12-08

ENGINE STALLING

BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING…

Investigation EA00028 Opened 2000-12-28 · closed 2002-01-29

FUEL TANK PUNCTURE

Investigation EA03020 Opened 2003-10-07 · closed 2004-04-23

PASSENGER AIR BAG LID FAILURE

THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA)…

Investigation EA03020 Opened 2003-10-07 · closed 2004-04-23

PASSENGER AIR BAG LID FAILURE

THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA)…

Investigation EA07014 Opened 2007-09-28 · closed 2008-07-07

PASSENGER ENGINE COMPARTMENT FIRES

THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING…

Investigation EA07014 Opened 2007-09-28 · closed 2008-07-07

PASSENGER ENGINE COMPARTMENT FIRES

THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING…

Investigation PE00033 Opened 2000-08-10 · closed 2000-12-28

FUEL TANK PUNCTURE

THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.

Investigation PE03021 Opened 2003-05-23 · closed 2003-10-07

PASSENGER SIR DOOR MOUNTING STUD FAILURE

ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW…

Investigation PE07024 Opened 2007-05-10 · closed 2007-09-28

PASSENGER/ENGINE COMPARTMENT FIRES

MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Volkswagen Passat as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.