The 2003 Travel Supreme Motorhome has 3 NHTSA recall campaigns affecting an estimated 816 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 1 complaint with NHTSA, most often about the tires. Last updated July 5, 2026.
ON CERTAIN MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USES WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.
SHOULD THE BURNER TUBE FAIL, THE COOLANT HEATER COULD OVERHEAT, POSSIBLY RESULTING IN A FIRE.
VEHICLE SYSTEMS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR TRAVEL SUPREME AT 574-862-4484.
ON CERTAIN MOTORHOMES EQUIPPED WITH TUTHILL INDEPENDENT FRONT SUSPENSIONS, THE DEFECT IS INSUFFICIENT TIGHTENING TORQUE OF THE STEERING KNUCKLE CARRIER BOLT THAT MAY RESULT IN SEPARATION OF THE STEERING KNUCKLE FROM ONE OF THE CONTROL.
SHOULD THE STEERING KNUCKLE CARRIER SEPARATE FROM THE CONTROL ARM, THE OPERATOR COULD LOOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.
TUTHILL WILL NOTIFY ITS CUSTOMERS AND PROVIDE A RETROFIT KIT P/N K704627 FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TUTHILL TRANSPORT TECHNOLOGIES AT 800-225-7824 (EXT. #390) OR…
ON CERTAIN 38' AND 40' MOTOR HOMES, AN INSULATED FOIL HEAT SHIELD, APPLIED ABOVE THE ENGINE TURBO EXHAUST IN THE ENGINE COMPARTMENT AT THE REAR OF THE MOTOR HOME TO DEFECT HEAT, MAY DETACH FROM THE SURFACE.
THIS CONDITION CAN RESULT IN A FIRE CAUSING INJURY TO THE OCCUPANT(S) OF THE MOTOR HOME.
DEALERS WILL INSPECT THE UNIT TO DETERMINE IF THE SEAM TAPE WAS INSTALLED. THEY WILL RE-ATTACH THE FOIL AND ADD THE SEAM TAPE AS NEEDED. ALL UNITS WILL ALSO HAVE A METAL FABRICATED HEAT SHIELD INSTALLED ON THE SURFACE OF THE INSULATED FOIL DIRECTLY ABOVE THE ENGINE TURBO EXHAUST. OWNER NOTIFICATION IS EXPECTED TO…
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“In june 2003 I bought a 2003 travel supreme express 5th wheel trailer. This rv trailer had 6 new goodyear marathon p235/80r16 load range"d" tires. With less than 1000 miles on them I had the first of 3 tire failures. The first indication of a problem was a 4 inch bubble on the outside side wall. A…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2003 Travel Supreme Motorhome as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.