1996 Toyota Tacoma Recalls

Recalls on record Updated July 2026

The 1996 Toyota Tacoma has 1 NHTSA recall campaign affecting an estimated 90,000 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 321 complaints with NHTSA, most often about the structure. Last updated July 5, 2026.

Recall campaigns

SUSPENSION 96V129000 1996-07-10 90,000 affected
Defect

UNDER CERTAIN DRIVING CONDITIONS, THE FRONT SUSPENSION SUPPORT CAN CRACK LEADING TO FAILURE OF THE SUPPORT.

Consequence

THIS CONDITION CAN RESULT IN LOSS OF VEHICLE CONTROL.

Remedy

DEALERS WILL REPAIR THE SUSPENSION SUPPORT.

Complaints by component

STRUCTURE:BODY
25
SUSPENSION
22
SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
22
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
18
STRUCTURE:FRAME AND MEMBERS
17
SUSPENSION:FRONT
15
AIR BAGS:FRONTAL
12
11crashes10injuries1deaths
SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:LEAF
11
ENGINE AND ENGINE COOLING:ENGINE
10
TIRES:TREAD/BELT
10
1crashes1deaths
Total complaints321

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“I purchased truck in 2005 from toyota of nicholasville ky I heard there was a recall never received recall notice took truck to have brakes done mechanic refused to work on it because of dangerous frame holes rust can push in sides of frame with fingers and make a hole mechanic said it was very…”

STRUCTURE:BODY · reported 2021-03-15

“I purchased truck in 2005 from toyota of nicholasville ky I heard there was a recall never received recall notice took truck to have brakes done mechanic refused to work on it because of dangerous frame holes rust can push in sides of frame with fingers and make a hole mechanic said it was very…”

SUSPENSION · reported 2021-03-15

“Tl* the contact owns a 1996 toyota tacoma. The contact stated that while driving, the rear passenger's side of the vehicle started to lower. After stopping to inspect the vehicle, the contact discovered the rear center leaf spring had fractured and had also punctured the fuel tank causing the fuel…”

SUSPENSION · reported 2020-10-01

“Tl* the contact owns a 1996 toyota tacoma. The contact stated that the vehicle's frame was corroded with holes near the rear passenger side wheel. The contact stated that the vehicle was taken to an unknown dealer for the manufacturer warranted frame repair. When the contact arrived at the dealer,…”

STRUCTURE:BODY · reported 2019-08-16

“The frame on the passager side of the truck has rusted out? Will not pass state inspection.”

STRUCTURE:BODY · reported 2018-05-16

“Recall info, can't sell without paperwork on frame and new company in our city won't or can't give me proof that frame is ok”

UNKNOWN OR OTHER · reported 2017-10-12

“Only 114,000 miles, frame rusted through. Unsafe.”

STRUCTURE:BODY · reported 2017-08-01

“Tl* the contact owns a 1996 toyota tacoma. The contact stated that the passenger side suspension support was damaged. The contact received notification of nhtsa campaign number: 96v129000 (suspension); however, the parts to do the repair were unavailable. The contact stated that the manufacturer…”

SUSPENSION · reported 2017-07-03

Defect investigations

Investigation EA97015 Opened 1997-07-22 · closed 1998-09-21

TURN SIGNAL FAILURES

There is no summary currently available

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1996 Toyota Tacoma as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.