The 2024 Toyota Sienna Hybrid has 2 NHTSA recall campaigns affecting an estimated 167,888 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 82 complaints with NHTSA, most often about the unknown or other. Last updated July 20, 2026.
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to…
Consequence
An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy
Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
SEATS25V0860002025-02-13167,802 affected
Defect
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2021-2025 Sienna Hybrid vehicles. The bolts for the seatbacks on the third-row seat assemblies may not be tightened properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers…
Consequence
An improperly tightened seatback may not adequately restrain the occupant during a crash, increasing their risk of injury.
Remedy
Dealers will tighten the seat assembly bolts, free of charge. Owner notification letters were mailed April 1, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA05.
Complaints by component
UNKNOWN OR OTHER
16
SERVICE BRAKES
15
2crashes4injuries
VEHICLE SPEED CONTROL
7
1crashes
ENGINE
6
SEATS
5
1injuries
STRUCTURE:BODY
4
1injuries
POWER TRAIN
3
FORWARD COLLISION AVOIDANCE: WARNINGS
2
1crashes
FUEL/PROPULSION SYSTEM
2
SUSPENSION
2
Total complaints82
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Moving about 55 miles per hour on right lane of I-95 the jeep in front of me braked abruptly. I braked hard but as my sienna was quickly slowing down to stop, the brake pad felt spongy when it was slower and as I pressed even harder, it seemed to have stopped decelerating at that slower speed and…”
“Rear tail lights failed... Brake and signals work. This was repaired through the dealership. 4 connectors and housing replaced invoice shows part 909890-10942. I am writing to express my concern regarding repeated tail light failures on my black toyota sienna that appear to be caused by wiring…”
“When approaching a stop sign or light and while the brake is already engaged the car will accelerate lunging the car forward from 3-10ft while driver maintains the same pressure on the break pedal.”
“The power liftgate on my 2024 toyota sienna consistently fails to complete a full close-and-latch cycle. When activated, the liftgate begins its closing sequence normally but then aborts the cycle during the final stages of latching. The system emits an audible beeping signal and the liftgate…”
“I am the original owner of a 2024 toyota sienna hybrid (vin: [xxx]). The vehicle has required two significant engine repairs within the first 57,000 miles of ownership. Both repairs were performed at authorized toyota dealerships under warranty. Incident 1 — engine replacement (10,000 miles): at…”
“While applying the brake at the stop light. (25 to30 mile speed limit zone) the toyota hybrid sienna start to accelerate for split 5 or more seconds. I have to apply the brake harder even though I was already applying the brake to slow down because the light was red and the are several cars in…”
“The contact owns a 2024 toyota sienna. The contact stated that while approaching a stop light and pressing the brake pedal the vehicle crashed into the rear of a second vehicle. During the crash the collision avoidance system did not activate and no air bags had deployed. No injuries were…”
“What component or system failed or malfunctioned, and is it available for inspection upon request? -the engine malfunctioned. It is available for inspection. How was your safety or the safety of others put at risk? -the engine went out at 77k miles in the middle of driving with no warning. Could…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2024 Toyota Sienna Hybrid as of
July 20, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.