How many recalls does the 2006 Toyota RAV4 have?

The 2006 Toyota RAV4 has 11 NHTSA safety recall campaigns on record.

How do I check if my 2006 Toyota RAV4 has an open recall?

Enter your 17-character VIN at NHTSA's official recall lookup (nhtsa.gov/recalls) to see open, unrepaired recalls for your specific vehicle. Recall repairs are free.

What do owners complain about most on the 2006 Toyota RAV4?

Of 880 NHTSA complaints on file, the most-reported component is steering.

2006 Toyota RAV4 Recalls

Recalls on record Updated July 2026

The 2006 Toyota RAV4 has 11 NHTSA recall campaigns affecting an estimated 8,145,974 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 880 complaints with NHTSA, most often about the steering. Last updated July 5, 2026.

Recall campaigns

SUSPENSION 16V596000 2016-08-12 337,449 affected

Defect

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with…

Consequence

Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy

Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. …

SEATS 16V396000 2016-06-02 7,749 affected

Defect

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and…

Consequence

If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

SEAT BELTS 16V096000 2016-02-19 1,123,752 affected

Defect

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats…

Consequence

A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.

Remedy

Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.

VISIBILITY 15V689000 2015-10-22 1,814,284 affected

Defect

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. …

Consequence

If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy

Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's…

AIR BAGS 14V168000 2014-04-09 1,486,413 affected

Defect

Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral…

Consequence

If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.

Remedy

Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an…

SUSPENSION 13V383000 2013-08-28 780,584 affected

Defect

Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted…

Consequence

Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy

Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in…

SUSPENSION 12V373000 2012-08-02 780,584 affected

Defect

Consequence

Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy

Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331…

VEHICLE SPEED CONTROL 11V113000 2011-02-24 1,363,244 affected

Defect

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy

THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

EQUIPMENT 10V035000 2010-02-03 271,417 affected

Defect

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION…

Consequence

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

EQUIPMENT 10V036000 2010-02-03 153,418 affected

Defect

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

EQUIPMENT 09V223000 2009-06-15 27,080 affected

Defect

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Consequence

INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy

TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Complaints by component

STEERING

223

ENGINE

109

VEHICLE SPEED CONTROL

111

SUSPENSION

AIR BAGS

ELECTRICAL SYSTEM

POWER TRAIN

ENGINE AND ENGINE COOLING

UNKNOWN OR OTHER

POWER TRAIN:AUTOMATIC TRANSMISSION

Total complaints880

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Odometer fraud. The contact purchased a 2006 toyota rav4. The contact discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 122,000, and at the time of registration, it was discovered that the mileage was 199,694.”

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER · reported 2026-03-13

“For several months the 2006 rav4 with only 118k miles had been experiencing intermittent failure of power steering while driving at speeds between 5-20mph. These failures resulted in the steering wheel to become extremely difficult if not impossible to turn while the car is driving. In each…”

STEERING · reported 2025-07-02

“Rear subframe rusted out. I took it in because my car started sounding like the titanic after it hit an iceberg. The mechanic described it as â€œa giant hole in the bottom of the car.â€� I read there were recalls on frames for other toyotas, but we kept up with every recall on this vehicle and the…”

STRUCTURE:BODY · reported 2025-03-28

“The vehicle is owned and operated in costa rica. I submitted the vehicle for the 4 incomplete recall items associated with its vin. I was told by grupo purdy toyota of costa rica that manufacturer recall number g0v nhtsa recall number16v596 does not apply in costa rica and they declined to…”

SUSPENSION · reported 2024-11-18

“The contact owned a 2006 toyota rav4. The contact stated that while his wife was driving at an undisclosed speed, she heard a scraping and shuddering sound at the hood of the vehicle. The contact then stated that another vehicle noticed a spark underneath the vehicle and notified his wife. The…”

FIRERELATED · reported 2023-07-23

“Two days ago my car was driving perfectly on the highway. The oil pressure light turned on I turned off the highway immediately and put more oil in the car. At this point my car is consuming over a quart every week and I don't drive more than a couple of hundred miles every week. I've taken…”

ENGINE · reported 2023-02-21

“The contact owns a 2006 toyota rav4. The contact stated that while making a right or left turn, there was a loud popping sound coming from the steering wheel. There was no warning light illuminated. Additionally, the contact stated that the popping noise was progressively louder while steering to…”

STEERING:LINKAGES · reported 2022-07-25

“While my son was driving me the vehicles steering wheel locked and he was unable to steer the vehicle. It caused us to go off the road down a steep hill and wreck. Iâ€™ve never had any problems with this vehicle so it was completely unexpected. If there had been anyone in our path we wouldnâ€™t of…”

STEERING · reported 2022-05-09

Defect investigations

Investigation PE12013 Opened 2012-06-04 · closed 2012-09-13

Rear Suspension Arm Assembly Failure

In a letter dated August 1, 2012 Toyota Motor Engineering & Manufacturing North America, Inc. (Toyota) submitted a Defect Information Report (NHTSA Recall No. 12V-373) to the NHTSA identifying a safety defect regarding possible separation of the Rear Suspension Arm No. 1 Assembly (arm) at the threaded portion (shaft…

Investigation PE12013 Opened 2012-06-04 · closed 2012-09-13

Rear Suspension Arm Assembly Failure

Investigation PE12013 Opened 2012-06-04 · closed 2012-09-13