The 2021 Thor Motor Coach Hurricane has 2 NHTSA recall campaigns affecting an estimated 3,897 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 3 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT23V1210002023-02-241,836 affected
Defect
Thor Motor Coach (TMC) is recalling certain 2018-2021 Hurricane and Windsport recreational vehicles. The driver and front passenger overhead cabinets may detach.
Consequence
Overhead cabinets that detach while the vehicle is in motion can fall onto seat occupants, increasing the risk of a crash or injury.
Remedy
Dealers will inspect and reinstall the overhead cabinets, if necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000290.
Thor Motor Coach (Thor) is recalling certain 2019-2021 Hurricane and Windsport motorhomes, models 27B, 29M, 32T, 33X, 34J, 34R and 35M. The electronic control center circuit board may be damaged from voltages over 17 volts causing damage to the circuit board.
Consequence
A damaged circuit board could increase the risk of a fire.
Remedy
Thor will notify owners, and dealers will add an additional circuit module to the existing component board to provide reverse polarity and over-current protection, free of charge. The recall began October 20, 2020. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000203.
Complaints by component
ENGINE
1
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
1
UNKNOWN OR OTHER
1
Total complaints3
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The floor on my coach above the catalytic converter has become soft. I am being told it is from the heat from the catalytic converter. O called thor and was told there should be a heat shield there campong world of ashville says there is not a heat shield on it I have a picture no shield is…”
“The floor on my coach above the catalytic converter has become soft. I am being told it is from the heat from the catalytic converter. O called thor and was told there should be a heat shield there campong world of ashville says there is not a heat shield on it I have a picture no shield is…”
“The floor on my coach above the catalytic converter has become soft. I am being told it is from the heat from the catalytic converter. O called thor and was told there should be a heat shield there campong world of ashville says there is not a heat shield on it I have a picture no shield is…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2021 Thor Motor Coach Hurricane as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.