The 2007 Suzuki Gsx-R600 has 1 NHTSA recall campaign affecting an estimated 208,966 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 51 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Recall campaigns
SERVICE BRAKES13V4490002013-10-18208,966 affected
Defect
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2013 GSX-R600 and GSX-R750, and model year 2005-2013 GSX-R1000 motorcycles. In combination with older brake fluid, corrosion of the brake piston inside of the front brake master cylinder generates gas that may result in a reduction of fluid…
Consequence
As a result, front braking power may be reduced increasing the risk of a crash.
Remedy
Suzuki will notify owners, and dealers will replace the front brake master cylinder, free of charge. The recall began on November 18, 2013. Owners may contact Suzuki at 1-800-572-1490. Suzuki's campaign numbers for this recall are: 2A (31, 32, 33, 34, 35, and 36).
Complaints by component
ELECTRICAL SYSTEM
20
1crashes5fires2injuries
FUEL SYSTEM, GASOLINE
6
2crashes1injuries
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
4
ENGINE AND ENGINE COOLING
3
VEHICLE SPEED CONTROL
3
1crashes1injuries
EXTERIOR LIGHTING
2
POWER TRAIN
2
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
1
ELECTRICAL SYSTEM:IGNITION
1
ELECTRICAL SYSTEM:IGNITION:SWITCH
1
Total complaints51
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Faulty and/or terrible placement of the rectifier causing my bike to overcharge the battery. I am very lucky the battery didn't catch fire or explode. I have replaced the stator, rectifier, and battery before because of this problem, but this time was a lot worse. Why has suzuki not recalled the…”
“Rectifier and stator problem. Riding down the road the bike completely turns off. Pulled into a parking lot and smell smoke. I look at the rectifier and it is extremely hot with a small ember burning on the back of it. Bike will not turn on anymore. Looks to be a similar recall for bikes made in…”
“I've bought 2 batteries, 2 stators and 2 rectifiers because my motorcycle charging system is over charging and frying the whole charging system. It causes my bike to have a very rapid jolt/loss of power almost throwing me over the handlebars because it just falls on its face and dies. Then it…”
“Be cause of the factory location of the rectifier behind the radiator the rectifier will over heat and blowup causing a short in the electrical or catch on fire researching and finding out this is a common issue the manufacture should replace the rectifier and stator to provent death while riding…”
“Regulator rectifier recall I believe this condition to be caused by defective regulator/rectifier. There is a recall for late 2007- 2008 models, however my bike is not included. Faulty engineering location behind radiator causing over heating condition in addition to faulty adhesive material. Both…”
“Regulator rectifier recall I believe this condition to be caused by defective regulator/rectifier. There is a recall for late 2007- 2008 models, however my bike is not included. Faulty engineering location behind radiator causing over heating condition in addition to faulty adhesive material. Both…”
“I was on the interstate going 68 mph when my motorcycle rpm's stopped working and turned to zero. I lost power suddenly after bike just shut off in the left lane. I had to push bike across moving traffic to get to the right side of road with shoulder to stop. Bike was towed to dealer and they say…”
“Tl* the contact owns a 2007 suzuki gsx-r600. While driving at approximately 20 mph, the engine stalled without warning. The failure recurred twice. The engine restarted after receiving a jump from another vehicle. The second time the failure recurred, the vehicle did not restart. The vehicle was…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2007 Suzuki Gsx-R600 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.