The 2006 Suzuki Forenza has 4 NHTSA recall campaigns affecting an estimated 455,592 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 426 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running light (DRL) module which could melt the…
Consequence
If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased risk of a fire.
Remedy
Suzuki will replace the signal switch and add a jumper relay kit and will replace the DRL Module in teh instrument panel harness. Suzuki distributed to owners an interim letter on July 30, 2014. The recall began October 29, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's number for this recall is XA.
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power…
Consequence
If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy
Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
Consequence
INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
Remedy
DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRL FREE OF CHARGE. THE RECALL WILL BE MAILED IN THREE PHASES, STARTING AT THE END OF OCTOBER 2007 AND CONCLUDING BY THE END OF JANUARY 2008;. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
SEAT BELTS07V3150002007-07-2475,697 affected
Defect
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT TONGUE WILL NOT LATCH INTO THE BUCKLE AND, IN RARE CASES, EVEN THE LOCKED TONGUE WILL POP OUT BY LOW STRETCHING FORCE. IF THE BUCKLE DOES NOT LATCH COMPLETELY, THE BUCKLE COULD RELEASE WITHOUT PRESSING THE RELEASE BUTTON.
Consequence
THESE BUCKLE MALFUNCTIONS, WHICH COULD PREVENT A PERSON FROM USING THE SEAT BELT OR COULD CAUSE THE SEAT BELT TO FAIL TO FUNCTION AS DESIGNED, CAN INCREASE THE RISK OF INJURY IN A CRASH.
Remedy
DEALERS WILL REPLACE THE FRONT DRIVER AND PASSENGER SEAT BELT BUCKLES WITH THE IMPROVED PART FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2007. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
Complaints by component
POWER TRAIN
69
1crashes
ELECTRICAL SYSTEM
48
1crashes4fires1injuries
POWER TRAIN:AUTOMATIC TRANSMISSION
48
1crashes1injuries
AIR BAGS
37
7crashes1fires13injuries
VEHICLE SPEED CONTROL
28
1crashes
EXTERIOR LIGHTING
21
1fires
ENGINE AND ENGINE COOLING
16
ENGINE
15
AIR BAGS:FRONTAL
11
5crashes1fires7injuries
SUSPENSION
11
Total complaints426
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“On march 6th 2018 I was involved in an accident with a volkswagen gti I was sitting in the left turn lane in the intersection waiting for traffic to clear so I could proceed when I did I was going approximately 5 miles per hour on a city street when a red light runner of course ran the red light…”
“Iba en mi vehiculo andando de noche con las luces prendidas y derrepente se prendieron las luces altas sin que yo hciera nada desde ese momento pareciera que hiciera un corto la luz y se ponen altas y vuelven normal mientras voy conduciendo adicional la parte del tablero se esta recalentando mucho…”
“Iba en mi vehiculo andando de noche con las luces prendidas y derrepente se prendieron las luces altas sin que yo hciera nada desde ese momento pareciera que hiciera un corto la luz y se ponen altas y vuelven normal mientras voy conduciendo adicional la parte del tablero se esta recalentando mucho…”
“Tl* the contact owns a 2006 suzuki forenza. While driving at night, the headlights and instrument panel lighting failed to illuminate. The vehicle was taken to an independent mechanic where it was diagnosed that the headlights and instrument panel lighting needed to be replaced. The vehicle was…”
“Tl* the contact owns a 2006 suzuki forenza. While driving at night, the headlights and instrument panel lighting failed to illuminate. The vehicle was taken to an independent mechanic where it was diagnosed that the headlights and instrument panel lighting needed to be replaced. The vehicle was…”
“The vehicle is under a recall campaign (xa-xc) for drl module/ignition switch replacement. The owner is physically unable to get the vehicle to the nearest dealership for the repairs to be performed (he is prohibited by his physician to drive such long distances). Suzuki will not allow any other…”
“I started my car and a few seconds later the airbag in the driver seat went off and the airbag hit me. The car was stationary.”
“While driving the cars check engine light will show up. I lose all control of speed even while pushing the gas pedal in. The only way to regain control is to cycle the key multiple times and let it idle in neutral for five minutes. After I regain control the check engine light is still on, and the…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2006 Suzuki Forenza as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.