2005 Suzuki C90 Recalls
No NHTSA recalls on record for the 2005 Suzuki C90. That means NHTSA has no open safety campaign for this vehicle — it does not guarantee the absence of problems. Owners have filed 9 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Complaints by component
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“Tl* the contact owns a 2005 suzuki c90. The contact stated that the motorcycle hesitated and failed to shift gears at low and high speeds. The gear shift fractured due to the failure and the contact had to replace the part. In addition, the battery was replaced four times and taken to the dealer…”
“Tl* the contact owns a 2005 suzuki c90. The contact stated that the motorcycle hesitated and failed to shift gears at low and high speeds. The gear shift fractured due to the failure and the contact had to replace the part. In addition, the battery was replaced four times and taken to the dealer…”
“The generator (stator) shorted to ground. *tr”
“The motorcycle start-up is not consistent. More often than not the main high beam light would dim indicating that there is battery, but it does not start, and when this happens you cannot even hear anything clicking. Start-up on the first try is less than 1% of the times. Internet research yields…”
“Fuel gauge quite working. Nothing was done to replace, as the sending unit is bad and you can not purchase a new sending unit. *tr”
“Charging led showed that the bike was not charging. Stator and voltage rectifier/regulator failed. The charging system was no longer charging the battery or supplying electricity to the electrical system. Replaced stator and voltage rectifier/regulator. Old stator is still available, threw out the…”
“I have a suzuki motorcycle it's 2005 c-50 boulevard not a c-90 as that is the only selection in the next menu. The speedometer is off by 6-8 miles an hour in the plus side so when I think I'm doing 60 I'm doing 53-54. I have checked the speed with another vehicle and a gps. I have been told it is…”
“Tl*the contact owns a 2005 suzuki c90 motorcycle. The contact received a recall notice for nhtsa campaign id number 06v025000 (fuel system, gasoline: storage: tank assembly) and immediately called the dealer. The technician procrastinated with scheduling an appointment for the recall repair. One…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2005 Suzuki C90 as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.