RecallRepo

2005 Sunnybrook 36bwks Recalls

Recalls on record Updated July 2026

The 2005 Sunnybrook 36bwks has 1 NHTSA recall campaign affecting an estimated 429 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 2 complaints with NHTSA, most often about the equipment. Last updated July 5, 2026.

Recall campaigns

WHEELS 05V423000 2005-09-23 429 affected
Defect

ON CERTAIN TOWABLE, NON-MOTORIZED, TRAVEL TRAILERS AND FIFTH WHEEL RECREATIONAL VEHICLES EQUIPPED WITH TREDIT WHEELS, THE RIMS MAY HAVE POOR WELD QUALITY AND INSUFFICIENT PRESS FIT BETWEEN THE WHEEL RIM AND DISC.

Consequence

THE CENTER OF THE WHEEL COULD SEPARATE FROM THE RIM. THE WHEEL MAY WOBBLE AND CAUSE A VIBRATION OR THE MOUNTED TIRE COULD LOSE AIR CAUSING THE TIRE TO GO FLAT, RESULTING IN A LOSS OF CONTROL OF THE VEHICLE AND INCREASING THE RISK OF A CRASH.

Remedy

SUNNYBROOK IS WORKING WITH TREDIT TIRE TO NOTIFY OWNERS AND HAVE THE WHEELS REPLACED. THE RECALL BEGAN ON OCTOBER 28, 2005. OWNERS MAY CONTACT SUNNYBROOK AT 574-825-5250.

Complaints by component

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
1
TIRES:SIDEWALL
1
Total complaints2

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Tl*the contact owns a 2005 sunnybrook 36bwks. The vehicle has nanco tires. The contact stated that all the sidewalls on the tires have dry rotted. The spare, which had never been used, was also cracked. The original tires had the same failure. The tire company sent four new tires, but they failed…”

TIRES:SIDEWALL · reported 2007-07-20

“Water leaked from the shower. Dealership retightened the shower. Trailer was then stored for 5 days. Upon picking up the trailer gallons of water leaked underneath the trailer. Then, trailer was taken back to dealership, and was kept for 6 days, in which the water pressure was checked. No leaks…”

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER · reported 2005-01-15

Defect investigations

Investigation PE05024 Opened 2005-05-10 · closed 2005-09-26

CRACKED OR BROKEN WHEELS

IN RESPONSE TO THE PRODUCT FAILURES THAT PROMPTED ODI TO INITIATE INVESTIGATION PE05-024, SUNNYBROOK RV HAS FILED DEFECT NOTICE 05V-423 THAT PROPOSES TO CONDUCT A PRODUCT RECALL TO REPLACE CERTAIN 16 CHROME PLATED STEEL WHEELS THAT WERE INSTALLED AS ORIGINAL EQUIPMENT BETWEEN FEBRUARY 1, 2005 AND JULY 11, 2005 IN…

Investigation PE05024 Opened 2005-05-10 · closed 2005-09-26

CRACKED OR BROKEN WHEELS

IN RESPONSE TO THE PRODUCT FAILURES THAT PROMPTED ODI TO INITIATE INVESTIGATION PE05-024, SUNNYBROOK RV HAS FILED DEFECT NOTICE 05V-423 THAT PROPOSES TO CONDUCT A PRODUCT RECALL TO REPLACE CERTAIN 16 CHROME PLATED STEEL WHEELS THAT WERE INSTALLED AS ORIGINAL EQUIPMENT BETWEEN FEBRUARY 1, 2005 AND JULY 11, 2005 IN…

Investigation PE05024 Opened 2005-05-10 · closed 2005-09-26

CRACKED OR BROKEN WHEELS

IN RESPONSE TO THE PRODUCT FAILURES THAT PROMPTED ODI TO INITIATE INVESTIGATION PE05-024, SUNNYBROOK RV HAS FILED DEFECT NOTICE 05V-423 THAT PROPOSES TO CONDUCT A PRODUCT RECALL TO REPLACE CERTAIN 16 CHROME PLATED STEEL WHEELS THAT WERE INSTALLED AS ORIGINAL EQUIPMENT BETWEEN FEBRUARY 1, 2005 AND JULY 11, 2005 IN…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2005 Sunnybrook 36bwks as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.