The 2000 Pontiac Montana has 5 NHTSA recall campaigns affecting an estimated 1,599,590 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 310 complaints with NHTSA, most often about the structure. Last updated July 5, 2026.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence
IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy
DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR…
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS…
Consequence
IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy
DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT…
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence
AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy
DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT…
SEAT BELTS00V2280032000-08-07156,305 affected
Defect
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY…
Consequence
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy
DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."
Consequence
IN A VEHICLE ROLLOVER ACCIDENT, IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy
DEALERS WILL INSPECT THE VEHICLES TO LOCATE AND REPLACE THOSE FUEL TANKS THAT COULD HAVE INOPERATIVE ROLLOVER VALVES.
Complaints by component
STRUCTURE:BODY:DOOR
25
8injuries
ENGINE AND ENGINE COOLING
20
ENGINE AND ENGINE COOLING:COOLING SYSTEM
15
ENGINE AND ENGINE COOLING:ENGINE
12
AIR BAGS
11
4crashes3injuries
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
10
1fires
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
10
2injuries
POWER TRAIN:AUTOMATIC TRANSMISSION
10
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
9
SERVICE BRAKES, HYDRAULIC
8
Total complaints310
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Shifting out of park while engine not running without the brake being on/stepped on, which resulted in the van rolling in reverse, thankfully it was in the driveway when this happen, was able to put it back into park (thank god).”
“Tl* the contact owns a 2000 pontiac montana. The contact stated that when the vehicle was pulled into the driveway, there was a loud noise under the vehicle. In addition, the steering wheel became loose and the rear axle support bracket detached from the vehicle. The vehicle was not diagnosed or…”
“Tl* the contact owns a 2000 pontiac montana. The contact stated that when the vehicle was pulled into the driveway, there was a loud noise under the vehicle. In addition, the steering wheel became loose and the rear axle support bracket detached from the vehicle. The vehicle was not diagnosed or…”
“I did not realize every owner of a pontiac montana all had same problems. Every owner. Here is one of the websites. Http://forums.edmunds.com/discussion/comment/3340529. The dealer sold me a pontiac montana. The second day I drove it, I ran out the gas because the gas gauge read full, but actually…”
“I did not realize every owner of a pontiac montana all had same problems. Every owner. Here is one of the websites. Http://forums.edmunds.com/discussion/comment/3340529. The dealer sold me a pontiac montana. The second day I drove it, I ran out the gas because the gas gauge read full, but actually…”
“I did not realize every owner of a pontiac montana all had same problems. Every owner. Here is one of the websites. Http://forums.edmunds.com/discussion/comment/3340529. The dealer sold me a pontiac montana. The second day I drove it, I ran out the gas because the gas gauge read full, but actually…”
“This is a addon from the previous one I submitted just now. I want to point out. I was almost killed when I ran out of gas on the highway, because the gas gauge read incorrectly. When the engine become hot, it almost started a fire. I am a single parent with a ten year old. Dealers are still…”
“This is a addon from the previous one I submitted just now. I want to point out. I was almost killed when I ran out of gas on the highway, because the gas gauge read incorrectly. When the engine become hot, it almost started a fire. I am a single parent with a ten year old. Dealers are still…”
Defect investigations
InvestigationEA01014 Opened 2001-06-11 · closed 2002-08-26
AIR BAG INFLATOR
InvestigationEA01014 Opened 2001-06-11 · closed 2002-08-26
AIR BAG INFLATOR
InvestigationPE02017 Opened 2002-02-11 · closed 2002-08-02
SHOULDER HARNESS CLIP
InvestigationPE04064 Opened 2004-09-17 · closed 2004-12-22
POWER-SLIDING DOOR
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING…
InvestigationSQ00014 Opened 2000-07-25 · closed 2001-10-22
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Pontiac Montana as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.