RecallRepo

2009 Peterbilt 335 Recalls

Recalls on record Updated July 2026

The 2009 Peterbilt 335 has 3 NHTSA recall campaigns affecting an estimated 461,693 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 2 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.

Recall campaigns

ELECTRONIC STABILITY CONTROL (ESC) 20V199000 2020-04-06 460,515 affected
Defect

PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System…

Consequence

If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.

Remedy

PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at…

ENGINE AND ENGINE COOLING 09V348000 2009-09-03 135 affected
Defect

PACCAR IS RECALLING MODEL YEAR 2008-2010 KENWORTH T300, T270, AND T370, MODEL YEAR 2009-2010 T800 AND PETERBILT MODEL YEAR 2008-2010 335, 340, AND 367 VEHICLES BUILT ON CUMMINS' DIESEL ENGINE. THE VEHICLES MAY BE DESIGNED WITH A HARD WIRED, DASH-MOUNTED SWITCH THAT ENABLES THE VEHICLE OPERATOR TO INHIBIT…

Consequence

THIS CONDITION WILL PERMIT HOT EXHAUST GASES TO EXIT THE VEHICLE TAILPIPE, INCREASING THE RISK OF MELTING OR BURNING OF NEARBY SURFACES, OR A FIRE.

Remedy

PACCAR IS WORKING WITH CUMMINS TO REPAIR THE ENGINES FREE OF CHARGE PLEASE SEE 09E-046. THE SAFETY RECALL BEGAN ON OCTOBER 1, 2009. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS (1-800-343-7357).

PARKING BRAKE 08V128000 2008-03-21 1,043 affected
Defect

PACCAR IS RECALLING 1,043 MY 2008-2009 KENWORTH C500, T2000,T660, T800 AND W900 TRUCKS EQUIPPED WITH BENDIX MV-3 DASH CONTROL VALVES. THE MOLDED VALVE BODY HAS AN INCORRECT CORE PIN IN THE INJECTION MOLD CAUSING THE VALVE BODY TO BE OVERSIZED IN THE DOUBLE CHECK VALVE AREA. THIS CONDITION CAN ALLOW THE RUBBER…

Consequence

IF THE DOUBLE CHECK VALVE BECOMES LODGED, IN THE EVENT OF A PRIMARY RESERVOIR FAILURE, AIR PRESSURE CAN LEAK PAST THE LODGED DOUBLE CHECK VALVE THEREBY DEPLETING THE SECONDARY RESERVOIR, CAUSING REDUCED ABILITY FOR MODULATING THE SERVICE EMERGENCY BRAKES. IN SUCH AN EVENT, THE OPERATOR SHOULD OBSERVE AN AIR LEAK,…

Remedy

DEALERS WILL REPLACE THE BENDIX MV-3 DASH CONTROL VALVES FREE OF CHARGE. THE RECALL BEGAN ON APRIL 14, 2008. OWNERS MAY CONTACT KENWORTH AT 1-425-828-4196.

Complaints by component

ENGINE
1
SERVICE BRAKES, AIR
1
Total complaints2

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“This six vehicle fleet reports that one vehicle (of the six) exhibited pull to right. Owner investigation found a fractured front brake (most likely the air chamber mounting bracket). Opposite side front brake was found cracked. Updated 06/29/10 *bf the right front air chamber broke off. Updated…”

SERVICE BRAKES, AIR · reported 2010-04-23

“Tl* the contact owns a 2009 peterbilt conventional 335. While attempting to utilize the dash mounted regeneration switch, it failed. The contact stated that the vehicle would also exhibit diminished horsepower. The vehicle was taken to the dealer where it was diagnosed, but the details of the…”

ENGINE · reported 2008-09-12

Defect investigations

Investigation PE20006 Opened 2020-05-01 · closed 2024-03-27

Intermittent Loss of Power Steering Assist

On May 1, 2020, the Office of Defects Investigation (ODI) opened PE20006 to investigate complaints of intermittent loss of power steering assist in Daimler Truck North America (DTNA), Volvo Trucks of North America (Volvo) and PACCAR vehicles equipped with a ZF/TRW (TRW) THP60 steering gear.  The investigation…

Investigation PE20006 Opened 2020-05-01 · closed 2024-03-27

Intermittent Loss of Power Steering Assist

On May 1, 2020, the Office of Defects Investigation (ODI) opened PE20006 to investigate complaints of intermittent loss of power steering assist in Daimler Truck North America (DTNA), Volvo Trucks of North America (Volvo) and PACCAR vehicles equipped with a ZF/TRW (TRW) THP60 steering gear.  The investigation…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2009 Peterbilt 335 as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.