How many recalls does the 2020 Motiv F-59 Bev Chassis School Bus have?

The 2020 Motiv F-59 Bev Chassis School Bus has 4 NHTSA safety recall campaigns on record.

How do I check if my 2020 Motiv F-59 Bev Chassis School Bus has an open recall?

Enter your 17-character VIN at NHTSA's official recall lookup (nhtsa.gov/recalls) to see open, unrepaired recalls for your specific vehicle. Recall repairs are free.

2020 Motiv F-59 Bev Chassis School Bus Recalls

Recalls on record Updated July 2026

The 2020 Motiv F-59 Bev Chassis School Bus has 4 NHTSA recall campaigns affecting an estimated 84 vehicles. Recall repairs are always free at any authorized dealer. Last updated July 5, 2026.

Recall campaigns

ELECTRICAL SYSTEM 25V262000 2025-04-21 3 affected

Defect

Motiv Power Systems, Inc. (Motiv) is recalling certain 2020 F-59 school buses equipped with a Motiv Gen 5 EPIC powertrain. A support bracket may fatigue and break, allowing the main power disconnect to contact other structures and short.

Consequence

An electrical short can shut down the high voltage system, resulting in a loss of drive power and increasing the risk of a crash.

Remedy

Motiv field support technicians will replace the bracket, free of charge. Owner notification letters were mailed June 9, 2025. Owners may contact Motiv customer service at 1-650-458-4804.

VEHICLE SPEED CONTROL 25V138000 2025-03-03 40 affected

Defect

Motiv Power Systems, Inc. (Motiv) is recalling certain 2017-2020 E-450 and F-59 school buses with Gen 4 EPIC powertrain, and 2020-2023 E-450, F-59, and F-53 school buses with a Gen 5 EPIC powertrain. A throttle position sensor (TPS) power wire connector pin may loosen, causing a loss of signal to the powertrain…

Consequence

Loss of drive power increases the risk of a crash.

Remedy

Motiv field support technicians will inspect and repair, or replace the PCM connector, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Motiv customer service at 1-650-458-4804.

ELECTRICAL SYSTEM 24V699000 2024-09-19 13 affected

Defect

Motiv Power Systems, Inc. (Motiv) is recalling certain 2017-2020 F-59 school buses equipped with a Motiv Gen 4 EPIC and 2020-2023 F-59 school buses equipped with a Motiv Gen 5 EPIC powertrain. The wiring harness may be missing a heat shrink insulator and retention clip. The 12-volt control wires may deteriorate and…

Consequence

A loss of drive power increases the risk of a crash.

Remedy

Motiv field support technicians will inspect and correct or replace any 12-volt control wires showing signs of fatigue, cracking, or improper retention or protection as necessary, free of charge. Owner notification letters were mailed November 21, 2024. Owners may contact Motiv customer service at 1-650-458-4804.

ELECTRICAL SYSTEM 24V602000 2024-08-12 28 affected

Defect

Motiv Power Systems, Inc. (Motiv) is recalling certain 2021-2023 F-450 and 2020 F-59 school buses equipped with a Motiv Gen 5 EPIC powertrain. The vehicle control software could misclassify a loss of isolation between the chassis and high voltage system, shutting down the high voltage (HV) batteries.

Consequence

The shutdown of the HV batteries can cause a loss of steering and brake power assist, and drive power, increasing the risk of a crash.

Remedy

Motiv will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 5, 2024. Owners may contact Motiv customer service at 1-650-458-4804.

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2020 Motiv F-59 Bev Chassis School Bus as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.