The 2007 Keystone Raptor has 3 NHTSA recall campaigns affecting an estimated 1,206,453 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 9 complaints with NHTSA, most often about the tires. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT17V7550002017-11-221,205,997 affected
Defect
Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf.…
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy
Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on…
EQUIPMENT07V2450002007-06-07152 affected
Defect
CERTAIN TRAVEL AND FIFTH WHEEL TRAILERS HAVE INCORRECT INFORMATION ON THE FEDERAL IDENTIFICATION TAG AND THE TIRE AND LOADING INFORMATION LABEL.
Consequence
ON THE TRAVEL TRAILERS, THE GVWR AND THE AXLE RATING IS HIGHER THAN THE ACTUAL RATINGS FOR THE AXLES INSTALLED. LOADING THE VEHICLE BEYOND THE GVWR COULD RESULT IN POOR VEHICLE HANDLING AND INCREASED RISK OF PROPERTY AND A VEHICLE CRASH. ON THE FIFTH WHEEL TRAILERS, THE TIRE LOAD RANGE AND MAXIMUM INFLATION DATA ON…
Remedy
DEALERS WILL REPLACE THE FEDERAL IDENTIFICATION LABELS AND THE TIRE AND LOADING INFORMATION LABELS. THE RECALL BEGAN ON JUNE 26, 2007. OWNERS MAY CONTACT KEYSTONE AT 1-866-425-4369.
EQUIPMENT07V0490002007-02-12304 affected
Defect
ON CERTAIN FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH AN ELECTRIC BED LIFT OPTION, A WASHER MAY HAVE BEEN OMITTED DURING PRODUCTION.
Consequence
IF THE WASHER IS MISSING, THE BED PLATFORM MAY BECOME DISPLACED DURING TRANSIT. THIS COULD RESULT IN PERSONAL INJURY IF SOMEONE USES THE BED WHEN IT IS PARTIALLY DISPLACED AND DOES NOT NOTICE IT.
Remedy
DEALERS WILL INSPECT THE ELECTRIC BED LIFT SYSTEM AND INSTALL ANY MISSING WASHERS. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT KEYSTONE RV AT 1-866-425-4369.
Complaints by component
TIRES
5
STRUCTURE:BODY:DOOR
1
TIRES:TREAD/BELT
1
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
1
WHEELS
1
Total complaints9
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Tl* the contact owns a 2007 keystone raptor equipped with trailer king st radial tires, size: 235/85/r16 (na). While driving approximately 65 mph, the trailer began to shake and vibrate. After stopping to inspect the vehicle, it was discovered that both the front and rear passenger tires…”
“Tl* the contact owns a 2007 keystone raptor. While driving at various speeds, a passenger side tire became flat. The exact location of the tire was unknown. On another occasion, the contact stated that the tire wobbled and appeared to be out of round. The failure occurred on several occasions. The…”
“Tl* the contact owns a 2007 keystone raptor. While driving at various speeds, a passenger side tire became flat. The exact location of the tire was unknown. On another occasion, the contact stated that the tire wobbled and appeared to be out of round. The failure occurred on several occasions. The…”
“Third carlisle radial trail tire to blow on our three axle 34 foot rv trailer on september 14, 2009 while returning from minneapolis, traveling west on interstate 80 at 10:15 a.m. At about mile marker 272, near the east side of the kearney ne. Exit, the center road (driver) side carlisle tire on…”
“Second carlisle radial trail tire to blow on our three axle 34 foot rv trailer on september 10, 2009 while trailing north east on interstate 76 at 6:10 p.m. At about mile marker 112 between brush and sterling, colorado the rear curb (passenger) side carlisle tire on our three axle rv trailer blew…”
“First carlisle radial trail tire to blow on our three axle 34 foot rv trailer on august 12,2009 while traveling west through a 9 mile construction zone with two way traffic on the east bound side of interstate 80, about 73 miles east of council bluffs, iowa, the center carlisle tire on the curb…”
“Carlisle tires on 2007 keystone raptor 5th wheel trailer showed cracks in the sidewalls after only 1200 miles. Had to replace all 6 tires in nashville, tn at a cost of $906. , while on vacation there last month. Contacted carlisle in aiken, sc and filed a complaint june 25, 2009. They agreed to…”
“My keystone raptor 3814 had 2 blow outs that cause alot of damage. I made sure that the tires were properly inflated and that I wasn't over weight and I still had blow outs. The carlie 15" d rated tires that came on my raptor are too small. They only will hold #2550 per tire times 6 tires is less…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2007 Keystone Raptor as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.