RecallRepo

2008 Keystone Fuzion Recalls

Recalls on record Updated July 2026

The 2008 Keystone Fuzion has 4 NHTSA recall campaigns affecting an estimated 1,210,425 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 4 complaints with NHTSA, most often about the tires. Last updated July 5, 2026.

Recall campaigns

EQUIPMENT 17V755000 2017-11-22 1,205,997 affected
Defect

Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf.…

Consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy

Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on…

ELECTRICAL SYSTEM 15V561000 2015-09-04 3,585 affected
Defect

Keystone RV Company (Keystone) is recalling certain model year 2008-2009 Big Sky, Challenger, Everest, Fuzion, Montana, and Raptor travel trailers and fifth wheels equipped with an IOTA ITS-50R transfer switch. These transfer switches, used in vehicles wired to be powered by a generator, may fail when exposed to…

Consequence

As the transfer switch fails, it may overheat, increasing the risk of a fire.

Remedy

Keystone will notify owners, and dealers will replace the IOTA ITS-50R transfer switch with a different brand transfer switch, free of charge. The recall began on October 8, 2015. Owners may contact Keystone customer service by calling 1-866-425-4369. Keystone's number for this recall is 15-234.

EQUIPMENT 08V037000 2008-01-28 247 affected
Defect

ON CERTAIN FIFTH WHEEL TRAVEL TRAILERS, THE PROPANE HOSE FOR THE SLIDE ROOM IS TOO LONG ALLOWING THE HOSE TO DROOP TOO CLOSE TO THE TIRE. THE PROPANE LINE MAY BECOME DAMAGED AS A RESULT OF CONTACT WITH THE TIRE.

Consequence

A PROPANE LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy

DEALERS WILL REPLACE THE PROPANE HOSE WITH ONE OF SHORTER LENGTH AND WILL ALSO SHORTEN THE HOSE SUPPORT TO MOVE THE HOSE AWAY FROM THE TIRE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT KEYSTONE RV AT 1-866-425-4369.

EQUIPMENT 07V330000 2007-07-20 596 affected
Defect

CERTAIN FIFTH WHEEL RECREATIONAL TRAILERS MAY HAVE INCORRECT WIRING TO THE WATER HEATER. IF THE WIRING IS INCORRECT, THE GAS VALVE ON THE WATER HEATER COULD OPEN AND ALLOW LIQUID PROPANE (LP) GAS INTO THE BURNER TUBE WHEN THE ELECTRIC SWITCH IS TURNED ON.

Consequence

THIS COULD CAUSE AN INCREASED RISK OF FIRE, EXPLOSIONS, AND PERSONAL INJURY.

Remedy

DEALERS WILL INSPECT THE WIRING AND MAKE CORRECTIONS IF NECESSARY. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS MAY CONTACT KEYSTONE RV AT 1-866- 425-4369.

Complaints by component

TIRES
3
ELECTRICAL SYSTEM
1
1fires
Total complaints4

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Tl* the contact owns a 2008 keystone fuzion. The contact received notification of nhtsa campaign number: 15v561000 (electrical system) however, the contact smelled an odor coming from under the front of the camper in the storage area. The contact extinguished the fire. No injuries were sustained.…”

ELECTRICAL SYSTEM · reported 2015-09-13

“Towing 5th wheel camper down interstate. All 4 tires on trailer developed bulges and 2 blew out. Damage wasn't too bad but caused a major disruption in travel. Had to buy 4 new tires for camper.”

TIRES · reported 2012-08-05

“3.5 hours into trip from roseville, ca to sand mountain, nv, we stopped at pilot truck stop to rendezvous with others in group. No potholes/curbs had been encountered. After approximately a 45 minute stop, we started again, and as we accelerated to 60mph on I-80, 1mile east of fernley, the front…”

TIRES · reported 2009-11-26

“On july 16, 2009 we were heading in out in our fifth wheel, we were on I-15 heading south in utah and one of our tires had a blow out, we called our roadside assistance and the came and installed our spare tire. Then upon returning back home on july 19, 2009 we had another tire blow out on the…”

TIRES · reported 2009-07-16
Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2008 Keystone Fuzion as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.