The 2005 Itasca Suncruiser has 6 NHTSA recall campaigns affecting an estimated 32,126 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 5 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT10V5250002010-10-2618,461 affected
Defect
WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. …
Consequence
THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy
WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT…
WINNEBAGO IS RECALLING 2,331 MY 2002-2004 BRAVE AND ITASCA SUNRISE MY 2005 2006 WINNEBAGO VOYAGE, ADVENTURER, ITASCA SUNRISE AND SUNCRUISER MOTOR HOMES. THE PROPANE TANK MOUNTING BRACKET MAY HAVE AN INCOMPLETE OR IMPROPER WELD.
Consequence
SHOULD THE WELD FAIL, THE PROPANE TANK CAN TIP OR FALL, POSSIBLY RELEASING PROPANE WHICH HAS THE POTENTIAL TO IGNITEA FIRE, RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
Remedy
DEALERS WILL INSPECT AND PROPERLY WELD THE BRACKET FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT WINNEBAGO AT 800-537-1885.
EQUIPMENT05V4070002005-09-141,367 affected
Defect
ON CERTAIN MOTOR HOMES, THE ROOF VENT FOR THE OPTIONAL 4-DOOR REFRIGERATOR WAS INCORRECTLY LOCATED.
Consequence
THIS CAN ALLOW EXCESSIVE HEAT BUILDUP WHICH HAS THE POTENTIAL TO IGNITE SURROUNDING MATERIALS, RESULTING IN PERSONAL INJURY AND/OI VEHICLE AND PROPERTY DAMAGE.
Remedy
DEALERS WILL RELOCATE THE ROOF VENT. THE RECALL BEGAN ON SEPTEMBER 9, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.
EQUIPMENT05V0770002005-03-02228 affected
Defect
CERTAIN MOTOR HOMES BUILT ON 24,000-LB GROSS VEHICLE WEIGHT RATING (GVWR)WORKHORSE CHASSIS WITH 235/80R22.5G XRV TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE MOTOR HOMES WERE INADVERTENTLY…
Consequence
FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS AND TIRE INFLATION RECOMMENDATIONS CAN RESULT IN TIRE DAMAGE AND VEHICLE INSTABILITY, WHICH COULD RESULT IN A CRASH.
Remedy
OWNERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT TIRE INFLATION INFORMATION. IF AN OWNER DESIRES, THEIR DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 24, 2005. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.
ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.
Consequence
WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy
DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.
SEAT BELTS04V6080002004-12-186,201 affected
Defect
CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence
THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy
DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.
Complaints by component
ELECTRICAL SYSTEM
1
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
1
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
1
SERVICE BRAKES
1
SERVICE BRAKES, HYDRAULIC
1
Total complaints5
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“While driving my itasca suncruiser motorhome to cobb & son rv repair I noticed I was unable to maintain normal speed. Arrived at cobb and explained to ritchie cobb the problem I was having. Ritchie had a tech measure the heat at the brakes and they were at 900 degrees. Informed recall from…”
“On november 10, 2011 I was having recall #51101-c completed on my motor home. The mechanic had the brakes apart to replace the bosch brake calipers and he discovered all four rotors had 2 -3 cracks on the outside plate. The cracks started on the outside edge and radiated in about 2 inches. The…”
“Driving on route 281 from brownsville tx. To san antonio tx. In my 2005 itasca suncruiser. At about 65 mph my vehicle started to drift on the road. Trying to correct it I found I had no steering...I put on my brakes and found I had no brakes. I was scared and did not know what to do. The dash…”
“Gas tank leaking. *jb”
“Dt*: the contact stated there was a smell of something overheating in a reclining couch within the coach. The vehicle had a switch used to disconnect the power to the living area of the motor home. The switch was tripped, and the contact reached in to the motor area of the seat. The motor was…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2005 Itasca Suncruiser as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.