The 2024 Ineos Grenadier has 3 NHTSA recall campaigns affecting an estimated 7,810 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 28 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Recall campaigns
STRUCTURE25V1470002025-03-067,022 affected
Defect
Ineos Automotive Americas, LLC (Ineos) is recalling certain 2024 Grenadier vehicles. The door button mechanism may have been assembled without a sufficient application of grease, preventing the door from fully latching.
Consequence
An unlatched door can open unexpectedly while the vehicle is in motion, increasing the risk of injury.
Remedy
Ineos will replace the door button assemblies, free of charge. Owner notification letters were mailed on September 12, 2025. Owners may contact Ineos customer service at 1-833-494-4748.
STEERING23V9030002023-12-2961 affected
Defect
Ineos Automotive Americas, LLC (Ineos) is recalling certain 2023-2024 Grenadier vehicles. Non-locking nuts may have been mistakenly installed on the steering rod ball joint.
Consequence
Loose or missing nuts can result in the steering rod ball joint disconnecting from the steering knuckle, causing a loss of steering and increasing the risk of a crash.
Remedy
Dealers will install locking steering rod ball joint nuts, free of charge. Owner notification letters were mailed June 25, 2024. Owners may contact Ineos customer service at 1-919-296-3626.
ELECTRICAL SYSTEM23V8280002023-12-07727 affected
Defect
Ineos Automotive Americas, LLC (Ineos) is recalling certain 2024 Grenadier vehicles equipped with the auxiliary switch package relay. The relay control wire may have been trapped under the relay power cable connection fastener during assembly, which can potentially damage the relay control wire insulation and result…
Consequence
A short circuit increases the risk of fire.
Remedy
Dealers will inspect and secure the wiring, and repair or replace any damaged wiring as necessary, free of charge. Owner notification letters were mailed June 25, 2024. Owners may contact Ineos customer service at 1-919-296-3626.
Complaints by component
ELECTRICAL SYSTEM
7
2injuries
SERVICE BRAKES
4
UNKNOWN OR OTHER
4
POWER TRAIN
3
STEERING
2
STRUCTURE:BODY
2
VISIBILITY/WIPER
2
AIR BAGS
1
FUEL/PROPULSION SYSTEM
1
SERVICE BRAKES, HYDRAULIC
1
Total complaints28
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“While driving my ineos grenadier in the middle of the arizona desert, the steering suddenly became difficult to control due to a tie rod nut coming loose. The vehicle began wandering and required constant correction to maintain control, creating a serious safety concern in a remote area far from…”
“Windsheild experienced a thermal crack that followed the length of the windscreen defrost vent. The crack began at each end of the vent traveled up about 2 inches and went horizontally across to the other end of the vent. Outside temps were in the single digits and it was snowing. Windscreen…”
“Hvac system is erratic and can blow very hot air when set to cool, so hot that it burned the top of my feet while driving and forced me to exit the freeway and shut the vehicle down. This failure is random, and properly written fault-tolerant software should not allow this condition to happen; it…”
“The contact owns a 2024 ineos grenadier. The contact stated that while taking his children to daycare and driving 35 mph, several unknown warning lights illuminated. The contact stated that the vehicle was hesitating while driving. The contact pulled into the parking lot. The contact stated that…”
“The contact owns a 2024 ineos grenadier. The contact stated that while taking his children to daycare and driving 35 mph, several unknown warning lights illuminated. The contact stated that the vehicle was hesitating while driving. The contact pulled into the parking lot. The contact stated that…”
“While traveling on a rough road I experienced a side curtain airbag deployment on our ineos grenadier. There was no impact or roll over. There was only one person in the vehicle, the driver, yet both the drivers side and passenger side airbags deployed along with the drivers seatbelt locking…”
“There appears to be some electrical malfunction that causes the air conditioning to produce exceptionally hot air. It can only end when the air conditioning system is turned all the way off. This is a known problem in the owners groups that many people are experiencing. One of my friends just…”
“The contact owns a 2024 ineos grenadier. The contact stated that while driving at an undisclosed speed, the a/c was activated; however, there was extremely hot air blowing out of the vents. No warning lights were illuminated. The contact stated that the vents were extremely hot and that the air…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2024 Ineos Grenadier as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.