RecallRepo

2005 Hyundai Tucson Recalls

Recalls on record Updated July 2026

The 2005 Hyundai Tucson has 8 NHTSA recall campaigns affecting an estimated 704,294 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 273 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

EXTERIOR LIGHTING 09V280000 2009-07-21 3,011 affected
Defect

HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE…

Consequence

ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.

Remedy

DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.

EXTERIOR LIGHTING 09V122000 2009-04-15 532,633 affected
Defect

HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE…

Consequence

ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.

Remedy

DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

AIR BAGS 07V197000 2007-05-08 2,967 affected
Defect

ON CERTAIN VEHICLES, STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED THAT A SMALL STATURE ADULT DRIVER NOT WEARING A SEAT BELT AND INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, THE DEPLOYMENT OF THE DRIVER AIR BAG MAY NOT OCCUR.

Consequence

THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.

Remedy

DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE WITH ONE THAT IS DESIGNED TO PROVIDE AN INCREASED MARGIN OF COMPLIANCE FOR LOW RISK DEPLOYMENT FOR SMALL STATURE ADULTS WHO ARE NOT PROPERLY WEARING THE SEAT BELTS. THE RECALL BEGAN ON SEPTEMBER 6, 2007, AND WILL BE PERFORMED IN TWO MAILINGS. OWNERS MAY CONTACT…

AIR BAGS 06V445000 2006-11-22 128,300 affected
Defect

ON CERTAIN SPORT UTILITY VEHICLES, DURING STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED IF A SMALL STATURED ADULT DRIVER, NOT WEARING A SEAT BELT, IS INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, DEPLOYMENT OF THE DRIVER AIR BAG MAY RESULT IN AN INSUFFICIENT…

Consequence

THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.

Remedy

DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. THE RECALL BEGAN ON JANUARY 29, 2007, AND WILL BE CONDUCTED THROUGH SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

PARKING BRAKE 05V342000 2005-07-27 330 affected
Defect

ON CERTAIN PASSENGER VEHICLES, THE PARKING LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MAY DAMAGE THE TEETH OF THE PARKING LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY ALLOW THE PARKING BRAKE TO RELEASE AFTER IT HAS BEEN ENGAGED.

Consequence

THE INABILITY TO ENGAGE OR THE INADVERTENT RELEASE OF THE PARKING BRAKE LEVER, MAY ALLOW YOUR VEHICLE TO ROLL WHILE IT IS PARKED AND MAY RESULT IN A CRASH.

Remedy

DEALERS WILL REPLACE THE PARKING BRAKE LEVER ASSEMBLY. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.

PARKING BRAKE 05V315000 2005-07-07 6,146 affected
Defect

ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MY DAMAGE THE TEETH OF THE PARKING BRAKE LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY ALLOW THE PARKING BRAKE TO RELEASE AFTER IT HAS BEEN ENGAGED.

Consequence

THE INABILITY TO ENGAGE, OR THE INADVERTENT RELEASE OF, THE PARKING BRAKE LEVER MAY ALLOW YOUR VEHICLE TO ROLL WHILE IT IS PARKED AND MAY RESULT IN A CRASH.

Remedy

DEALERS WILL REPLACE THE PARKING BRAKE LEVER ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

ELECTRONIC STABILITY CONTROL 05V177000 2005-04-27 349 affected
Defect

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE OF THE WHEELS TO BE INAPPROPRIATELY.

Consequence

BRAKE APPLICATION CAUSED BY INADVERTENT ESP ACTIVATION MAY RESULT IN LOSS OF CONTROL AND A CRASH.

Remedy

DEALERS WILL REPROGRAM THE ESP HYDRAULIC ELECTRONIC CONTROL UNIT. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2005. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.

ELECTRONIC STABILITY CONTROL 05V119000 2005-03-25 30,558 affected
Defect

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE OF THE WHEELS TO BE INAPPROPRIATELY.

Consequence

BRAKE APPLICATION CAUSED BY INADVERTENT ESP ACTIVATION MAY RESULT IN LOSS OF CONTROL AND A CRASH.

Remedy

DEALERS WILL REPROGRAM THE ESP HYDRAULIC ELECTRONIC CONTROL UNIT FREE OF CHARGE. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

Complaints by component

ELECTRICAL SYSTEM
25
1fires
AIR BAGS
22
5crashes1fires8injuries
ENGINE
18
ENGINE AND ENGINE COOLING
14
1crashes1injuries
SUSPENSION
13
1crashes
UNKNOWN OR OTHER
11
1fires
ELECTRONIC STABILITY CONTROL (ESC)
10
EXTERIOR LIGHTING
9
1fires
STRUCTURE
9
2crashes1injuries
VEHICLE SPEED CONTROL
9
1crashes
Total complaints273

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Caught on fire. Started under passager floor board. Burnt completely up”

UNKNOWN OR OTHER · reported 2023-11-03

“The contact owns a 2005 hyundai tucson. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front passenger side air bag wiring harness; however, the part was discontinued. The…”

AIR BAGS · reported 2023-06-28

“This car accelerates while unattended. Most likely due to an ecm malfunction and unable to properly respond/send signals to the motor. On 4 occasions, the car has accelerated, even if in park. It will go 25mph on its own and to stop I had to put it in neutral. I’ve seen that my car isn’t the…”

ELECTRICAL SYSTEM · reported 2023-01-31

“This car accelerates while unattended. Most likely due to an ecm malfunction and unable to properly respond/send signals to the motor. On 4 occasions, the car has accelerated, even if in park. It will go 25mph on its own and to stop I had to put it in neutral. I’ve seen that my car isn’t the…”

ENGINE · reported 2023-01-31

“The contact owns a 2005 hyundai tucson. The contact stated that on several occasions while driving 65 mph and attempting to accelerate, the rpm failed to raise, and the vehicle failed to respond. No warning lights were illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor…”

ENGINE · reported 2022-10-25

“The contact owns a 2005 hyundai tucson. The contact stated that on several occasions while driving 65 mph and attempting to accelerate, the rpm failed to raise, and the vehicle failed to respond. No warning lights were illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor…”

POWER TRAIN · reported 2022-10-25

“Air bag light on dashboard esp light comes on and off”

AIR BAGS · reported 2022-06-09

“Air bag light on dashboard esp light comes on and off”

UNKNOWN OR OTHER · reported 2022-06-09

Defect investigations

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Investigation PE09003 Opened 2009-01-14 · closed 2009-04-24

STOP LAMP SWITCH FAILURE

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2005 Hyundai Tucson as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.