RecallRepo

2015 Heartland Cyclone Recalls

Recalls on record Updated July 2026

The 2015 Heartland Cyclone has 3 NHTSA recall campaigns affecting an estimated 5,416 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 5 complaints with NHTSA, most often about the structure. Last updated July 5, 2026.

Recall campaigns

EQUIPMENT 16V819000 2016-11-14 2,045 affected
Defect

Heartland Recreational Vehicles, LLC (Heartland) is recalling certain model year 2015-2016 Cyclone travel trailers manufactured July 6, 2014, to September 29, 2015 and 2015-2016 Road Warrior and 2016 Torque trailers manufactured July 18, 2014, to September 30, 2015. The affected trailers are equipped with aluminum…

Consequence

If the hinges separate from the ladder while in use, the ladder may fall from the vehicle, increasing the risk of injury.

Remedy

Heartland will notify owners, and dealers will install hinge braces over the back of the existing hinges, free of charge. The recall began on December 2, 2016. Owners may contact Heartland customer service at 1-877-262-8032. Heartland's number for this recall is 99-01-28.

EQUIPMENT 15V482000 2015-07-30 1,680 affected
Defect

Heartland Recreational Vehicles, LLC (Heartland) is recalling certain trailers of various models and model years. Click on "All Products Associated With This Recall" for a complete list. The tire certification labels applied to the vehicles may contain inaccurate tire sizing and/or inflation information. As such,…

Consequence

An owner or operator could rely on the inaccurate information in inflating the tires which could cause under or over inflation which, in turn, could lead to a tire failure or crash.

Remedy

Heartland will notify owners, and dealers will send a replacement label with the correct information, free of charge. The recall began on September 29, 2015. Owners may contact Heartland customer service at 1-574-266-3988.

EQUIPMENT 15V198000 2015-04-03 1,691 affected
Defect

Heartland Recreational Vehicles, LLC (Heartland) is recalling certain model year 2015 Bighorn, Cyclone, Edge, Elkridge, Landmark 365, Road Warrior, and Torque fifth wheel and travel trailers. In the affected vehicles, a rivet for the quad entry steps may shear and fail, causing the steps to give when being used.

Consequence

If the rivet shears causing the quad step to fail, the step user may fall, increasing the risk of personal injury.

Remedy

Heartland has notified owners, and dealers will replace the defective rivets with bolts, free of charge. The recall began on April 13, 2015. Owners may contact Heartland customer service at 1-877-262-8032. Heartland's number for this recall is 99-01-20.

Complaints by component

STRUCTURE:BODY
2
WHEELS
2
TIRES
1
Total complaints5

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Manufacturer incorrectly placed sticker showing where to drill a 4 inch hole in side of vehicle for a dryer vent. Cutting hole where shown actually cuts through an aluminum frame member as shown in attached pics degrading the structural integrity of the vehicle frame/body. *tt”

STRUCTURE:BODY · reported 2018-04-21

“Three separate blowouts over two trips of my dynamic tire, towmax str 235/85 16 e 10ply tires. First incident was a solo tire separation leaving only sidewalls on the rear driver side wheel. Second and third tires were on the same trip one day apart. Tire number two was a slow leak detected by my…”

WHEELS · reported 2017-04-20

“On 8/11/2015 while taking my cyclone 4200 in for service I had a tire blow out. I have only had the rv for 10 months and it has spent most of that time in the shop for warranty work. When I first purchased the rv I tried to get the dealer to change them out as I notice some indentations on the…”

STRUCTURE:BODY · reported 2015-08-11

“On 8/11/2015 while taking my cyclone 4200 in for service I had a tire blow out. I have only had the rv for 10 months and it has spent most of that time in the shop for warranty work. When I first purchased the rv I tried to get the dealer to change them out as I notice some indentations on the…”

WHEELS · reported 2015-08-11

“Driving onto an onramp from highway 20 on to I-80 east in california ~ 50 miles west of reno, nv. Traveling ~ 40mph; dry road condition and the outside temp was about 50 degress; towing our 2015 heartland 5th wheel rv. Blowout accrued with towmaxx str 235/80/r16. Caused $3000.00 to the rv.…”

TIRES · reported 2015-05-17
Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2015 Heartland Cyclone as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.