The 2004 Harley-Davidson Dyna Glide has 2 NHTSA recall campaigns affecting an estimated 7,421 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 5 complaints with NHTSA, most often about the fuel system, gasoline. Last updated July 5, 2026.
ON CERTAIN MOTORCYCLES, A CONDITION OCCURS THAT COULD ALLOW PRESSURE TO BUILD UP IN THE FUEL TANK. ON FUEL INJECTED VEHICLES, THIS CONDITION COULD CAUSE FUEL TO SPRAY OUT UNEXPECTEDLY WHEN THE FUEL CAP IS REMOVED. ON CARBURETED VEHICLES, EXCESSIVE FUEL COULD BE TRANSFERRED TO THE CARBURETOR, WHICH WOULD EVENTUALLY…
Consequence
THESE SITUATIONS COULD CAUSE SERIOUS PERSONAL INJURY OR CREATE A FIRE HAZARD FOR PERSONS OR PROPERTY ON OR NEAR THE MOTORCYCLE.
Remedy
DEALERS WILL TEST EACH CANISTER FOR BLOCKAGE, THEN REPLACE AS NECESSARY. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
ON CERTAIN FUEL INJECTED MOTORCYCLES, THE RUBBER FUEL HOSE HAS THE POTENTIAL TO SEPARATE FROM THE INNER LINER CAUSING A FUEL LEAK.
Consequence
THIS COULD RESULT IN A FIRE.
Remedy
DEALERS WILL REPLACE THE FUEL LINE ASSEMBLY. OWNER NOTIFICATION BEGAN ON FEBRUARY 12, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.
Complaints by component
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
1
POWER TRAIN:CLUTCH ASSEMBLY
1
POWER TRAIN:MANUAL TRANSMISSION
1
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
1
SUSPENSION:FRONT:WHEEL BEARING
1
Total complaints5
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Dt: the contact received nhtsa recall 04v465000 concerning the fuel tank storage assembly. Thwere not available. The dealership told her the parts may not be available for at least six more weeks. *nm.”
“Consumer just purchased a new harley-davidson, and the front wheel bearings were defective, causing the front wheel to wobble. This problem occurred once at 844 miles. Then, it happened again at 1149 miles. *ak the consumer had the motorcycle repaired spacer was in the front wheel . *tc”
“The rear brakes were not properly lubricated, which resulted in the rear brakes locking up and causing control problems. *ak *sc *jb”
“While motorcycle was parked consumer noticed fluid leaking from underneath. Consumer contacted the dealer to make an appointment for repairs. *ak the leak occurred in front of the rear tire which resulted in some of the fluid getting on the tire. The dealer has worked on the transmission 3 times…”
“I was riding down the interstate and the clutch bolt flew out of the derby cover I was lucky that it flew out insted of in the gear that would have locked my back wheele up and I would have crashed I took it to the harley shop of wytheville va and they told me it was unchecked by the harley shop…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2004 Harley-Davidson Dyna Glide as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.