The 2000 Gulf Stream Sun Voyager has 3 NHTSA recall campaigns affecting an estimated 40,178 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 6 complaints with NHTSA, most often about the suspension. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT08V3830002008-08-05413 affected
Defect
GULF STREAM IS RECALLING 413 MY 1999-2002 SUN VOYAGER, SCENIC CRUISE, FRIENDSHIP, AND TOUR MASTER MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
Consequence
EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Remedy
GULF STREAM IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E030). NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT NORCOLD AT 1-800-767-…
EQUIPMENT07V1360002007-03-2038,767 affected
Defect
CERTAIN MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy
GULF STREAM WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST…
SERVICE BRAKES, HYDRAULIC03V0920002003-03-12998 affected
Defect
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence
IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy
DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION IS BEGAN MAY 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GULF STREAM AT 1-574-773-7761.
Complaints by component
SUSPENSION
2
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
1
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
1
POWER TRAIN
1
STRUCTURE
1
Total complaints6
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Dt*: the contact stated while driving 55 mph, the motor home began to rock from side to side. As the vehicle slowed, the rocking subsided. As the vehicle sped up, the rocking became worse. The vehicle was taken to a service dealer, where the dealer was unable to determine the problem.*ak updated…”
“Dt*: the contact stated while driving 55 mph, the motor home began to rock from side to side. As the vehicle slowed, the rocking subsided. As the vehicle sped up, the rocking became worse. The vehicle was taken to a service dealer, where the dealer was unable to determine the problem.*ak updated…”
“Dt*: the contact stated while driving 55 mph, the motor home began to rock from side to side. As the vehicle slowed, the rocking subsided. As the vehicle sped up, the rocking became worse. The vehicle was taken to a service dealer, where the dealer was unable to determine the problem.*ak updated…”
“Severe problem with loss of control while drivng on rugged road at any speed, also while driving 60 mph or more in high winds it is hard to control. Dealer was notified. *ak consumer stated there is an exhaust smell inside of rv, there is also a noise in drive train, drivers seat will not adjust…”
“Severe problem with loss of control while drivng on rugged road at any speed, also while driving 60 mph or more in high winds it is hard to control. Dealer was notified. *ak consumer stated there is an exhaust smell inside of rv, there is also a noise in drive train, drivers seat will not adjust…”
“Severe problem with loss of control while drivng on rugged road at any speed, also while driving 60 mph or more in high winds it is hard to control. Dealer was notified. *ak consumer stated there is an exhaust smell inside of rv, there is also a noise in drive train, drivers seat will not adjust…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Gulf Stream Sun Voyager as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.